Académique Documents
Professionnel Documents
Culture Documents
c. Approximately 1200
d. Approximately 1.2
366. What is the flywheel effect?
a. The continued motion of a radio wave
through space when the transmitter is turned
off
b. The back and forth oscillation of electrons
in an LC circuit
c. The use of a capacitor in a power supply
to filter rectified AC
d. The transmission of a radio signal to a
distant station by several hops through the
ionosphere
367. How can parasitic oscillations be eliminated
from a power amplifier?
a. By tuning for maximum SWR
b. By tuning for maximum power output
c. By neutralization
d. By tuning the output
368. If the spectrum is shifted in frequency with no
other changes, this is known as
a. Frequency multiplication
b. Sideband movement
c. Baseband orientation
d. Frequency translation
369. A device which is capable of causing
frequency translation
a. High-Q tank circuit
b. Balanced modulator
c. Low-Q tank circuit
d. IF strip
370. If the frequency of each component in a signal
spectrum is increased by the same fixed amount,
this is known as
a. Up conversion
b. Demodulation
c. Frequency translation
d. Both a and c
371. A particular amplifier is designed to be a
frequency doubler. If the input signal frequency is
15.4 MHz, a circuit in the output will be tuned to
a. 7.7 MHz
b. 15.4 MHz
c. 30.8 MHz
d. 61.6 MHz
372. Any device to be used as a frequency
multiplier must be
a. Active
b. Passive
c. Linear
d. Nonlinear
c. Lower sideband
d. Baseband signal
390. A frequency multiplier circuit
a. Operates class A
b. Is tuned to a harmonic of the input signal
c. Needs parasitic oscillations
d. Is usually pulse modulated
391. An IF transformer of a radio receiver operates
at 456 kHz. The primary circuit has a Q of 50 and
the secondary has a Q of 40. Find the bandwidth
using the optimum coupling factor.
a. 10.192 kHz
b. 15.288 kHz
c. 152.88 kHz
d. 101.92 kHz
392. A varactor has a maximum capacitance of
80pF and is used in a tuned circuit with a 100
microhenry inductor. Find the tuning voltage
necessary for the circuit to resonate at twice its
resonant frequency with no tuning voltage applied.
a. 5 V
b. 2.5 V
c. 7.5 V
d. 4.25 V
393. A phase-locked loop has a VCO with a freerunning frequency of 14 MHz. As the frequency of
the reference input is gradually raised from zero, the
loop locks at 12 MHz and comes out of lock again
at 18 MHz. Calculate the capture range.
a. 4 MHz
b. 2 MHz
c. 12 MHz
d. 8 MHz
394. If the frequency fed to the pre-amplifier of a
basic transmitter with multipliers is composed of a
pair of triplers and a doubler is 198 MHz, what
frequency should the oscillator operate?
a. 11 MHz
b. 33 MHz
c. 22 MHz
d. 66 MHz
395. A phase-locked loop has a VCO with a free
running frequency of 14 MHz. As the frequency of
the reference input is gradually raised from zero, the
loop locks at 12 MHZ and comes out of lock again
at 18 MHz. Calculate the lock range.
a. 4 MHz
b. 2 MHz
c. 12 MHz
d. 8 MHz
362. It is stable
363. Efficiency = (RF power out / dc power in) x
100%
364. 14.4 ohms
365. Approximately 12
366. The back and forth oscillation of electrons in
an LC circuit
367. By neutralization
368. Frequency translation
369. Balanced modulator
370. Both a and c
371. 30.8 MHz
372. Nonlinear
373. Push-push
374. Frequency synthesizer
375. both A and B
376. Indirect
377. All of the above
378. The change of the crystal oscillator frequency
by loading
379. Both a and b
380. All of the above
381. SSB
382. Buffer amplifier
383. Signal bias
384. Pulse
385. Cancelling the effect of internal device
capacitance
386. Splatter
387. Class C
388. Minimum IC in the same stage
389. Carrier
390. Is tuned to a harmonic of the input signal
391. 15.288 kHz
392. 7.5 V
393. 4 MHz
394. 11 MHz
395. 8 MHz
396. 185 Hz
397. 6.25 W
398. 128 ohms
399. 56. 25 W
400. 15.625 ohms