; Basle Description
Sonic Nausea Machine ‘Your NAUSEA MACHINE produces high frequency secoustical
shergy that causes natisea, headaches, disorientation and general
nfortabiliy. ean be use to discourage people frm com
furniture, tbles et. Determining
source ofthe sound is ificul for most people ws they felt
NAUSEA1 SCHEMATIC
e e
10K Trimmer pot
2.2K 1/4 W (ved red,red)
10 ohm 1/4 WY (bbl)
100 nafa 25 V vertical electraly tie capacitor
047 raf 50 Vp
«lH mfdl 50 V dive capacitor
Lilt high Q inductors for (
555 DIF
Special plezocleetric transducer
Battery snap clip
Ld” X 1.6" 1 Grid perfboard
9 Volt transistor or 8.AA batteries for 12 volts.
Assemble board as shoun using the component leads for connec
3. Route wire runs as shown by dashed lines on assembly
‘and avoid bare Wire bridges, cold solder joints, potential
shorts and excess solder, Note proper position of 11 and polariza-
tion of C1
| Apply power viaa battery or bench supply and tune R1 for a clear
| piercing tone. If you have a scope, tune for a 30 to 40 volt sinusoi-
| dal wave of 15 khvzacross TDI. You may tune the eireuit for a
| higher frequency around 20 khz.by shorting Out one of the induc-
4 | tors. This is usually required if the circuit bothers people when
being used to control pets. Battery drain is around 50 ma and can,
range from 6 tol S volts.BOARD ASSEMBLY OF NAUSEA MACHINE om)
IF YOU ARE A BEGINNER WE SUGGEST OUR HGCATL GENERAL CONSTRUCTION TECHNIQUES