Académique Documents
Professionnel Documents
Culture Documents
Real-time clock
Controller Board
The controller board supports these connections:
Eight devices, with 1 digital input and 1 digital
output per device
Up to four zones, with staging for each zone
Four 4-20mA analog inputs (one sensor per zone)
Two programmable digital relay outputs
Two Common Alarm outputs
One EPOP input
Enclosure
The Liebert AC8 comes standard in an enclosure,
which features a key lock for added security. The
enclosure is made of metal to accommodate secure
conduit fittings and protect components against
environmental debris.
Liebert AC8 enclosure - External features
Knockouts and
access slots
on top and
bottom
Key
lock
LCD for
configuration
and operation
Keypad Display
The keypad is a user interface
mounted on the enclosure door of
the Liebert AC8. The liquid crystal
display (LCD) permits complete
Keypad
monitoring and configuration of the
panel and is password-protected.
The keypad display permits the Liebert AC8 to
operate as a complete stand-alone panel.
Audible horn
Battery pack
Common Alarm
connectors
Transformer
Module
TB5: COMMON ALARM
RELAY OUTPUTS
NO C NC (TOP)
NO C NC
Manual Override
Switch (outputs)
BOTTOM
LS1
TB7:
24V INPUT
START
P11
ENABLE
AUDIBLE
TB4:
TOP
Q11
LIEBERT
BAR CODE
P23:
BATTERY
BATTERY
(BOTTOM)
NC
C
NO
NC
C
NO
LCD
CONTRAST
TP1
VBATT
RELAY
OUTPUTS
GND
ON
S2
OFF
ON
1
DIP
3
OUTPUT1
OUTPUT2
OUTPUT3
OUTPUT4
OUTPUT5
OUTPUT6
OUTPUT7
OUTPUT8
CTRLLOCK
SENLOCK
CMN ALR
DS56
DS54
DS63
DS83
DS84
DS61
DS60
DS62
DS55
DS57
DS59
DS58
DS53
CAN TX
CAN RX
Modem
(BOTTOM)
(TOP)
4
3
MOP
F PROG
574 TX
574 RX
485 RX
485 TX
PFM2
7
6
5
REV
(BOTTOM)
(TOP)
Phone line
connector
3
2
ASS
TB1
8
7
EPOP
ON
P19
MODEM
DIS EN
J11: PHONE
PIN 3-TIP
PIN 4-RING
(TOP)
485
+
(BOTTOM)
422
+
AG TB9: ANALOG
GROUND
EPOP
Digital input
connectors
TB2:
CONTACT
INPUTS
EPOP INPUT
1-2 TOP
3-4 BOTTOM
Digital output
connectors
PFM5
R334
INPUT1
INPUT2
INPUT3
INPUT4
INPUT5
INPUT6
INPUT7
INPUT8
C71
DS70
DS67
DS66
DS65
DS64
MODEM
Power On/Off
switch
Control relay
outputs
EPOP contact
input
TB1: EPOP
CONTACT
INPUT
Power receptacle
Serial interface
connector (RS232 / EIA574)
SiteScan Web
connector (EIA422)
Analog input
connectors
18"
(457.2mm)
Front
view
Front
view
14"
(355.6mm)
18"
(457.2mm)
3.83"
(97.2mm)
Top/bottom
view
Top/bottom
view
2.85"
(72.39mm)
2.65"
(67.3mm)
Wiring Specifications
Connection
Rating
Dry Contact
(24VDC,
10 mA)
Digital
Input/
EPOP
Digital
Output/
Control
Relay
Analog Input
2-Wire
Transducer
4-20 mA Signal
Input Selectable
Power Source
(12/24VDC)
Analog Input
4-Wire
Transducer
4-20 mA Signal
Input Selectable
Power Source
(12/24VDC)
Common
Alarm
Output
Communication
RS232
Communication
EIA422
Liebert
SiteScan
Communication
EIA485
18 AWG*
(recommended)
20 AWG
22 AWG
18 AWG*
(recommended)
20 AWG
22 AWG
24VAC@3A
24VAC
@3A
50 ft. (15m)
N/A
N/A
N/A
N/A
N/A
24VAC
@1.3A
Phone/Modem
Line
24VAC Power
Connection
(TB7)
115VAC
@4A
230VAC
230VAC
@0.5A
* Recommended
Power
Requirements
115VAC 10% of nominal; 60Hz, 4A, 460VA 230VAC 10% of nominal; 50Hz, 0.5A, 115VA
18 x 2-3/4 x 18 (457.2 x 69.85 x 457.2)
20.56 lb. (9.33 kg)
NEMA 1
Four line, 20 character, backlit
Building Wall or Structural Member
32F to 104F (0C to 40C) 0% RH to 95% RH (non-condensing)
Motorola XC68HC812A4
16MHz
256Kb
4M
4K
12 Bit
14.4K bps
Real-Time Clock
Lithium Cell (non-replaceable)
7 years, constant, no power
Nickel Cadmium (replaceable)
10 minutes at full load
RS232
Baud rate 9600 bps, Parity=None, Data bits=8, Stop bits=1
9600 E-7-1 supports TAPI protocol version 1.8
IGM Protocol, EIA422
115VAC Transformer Module (TM115)
230VAC Transformer Module (TM230)
Agency Listings
UL
CSA
CE
FCC Compliance
Inputs & Outputs (Quantity)
Digital Inputs (8)
Analog Inputs (4)
Digital Outputs (8)
Common Alarm Outputs (2)
UL1012
UL1585
C22.2 No. 66 and C22.2 No. 107.1
Yes
N/A
Ordering Information
Quantity
Part #
AC8L115
AC8L230
201258P1
TW420
Description
Liebert AC8 controller board & Transformer Module 115VAC with two 24VAC outputs (40VA each) and
115VAC receptacle in enclosure
Liebert AC8 controller board & Transformer Module 230VAC with two 24VAC outputs (40VA each) in
enclosure
RS232 configuration cable
Temperature Transmitter Wall 4-20 mA @ 45F to 96F
Liebert Corporation
1050 Dearborn Drive
P.O. Box 29186
Columbus, OH 43229
Telephone: 1-800-877-9222
Facsimile: 1-614-841-6022
www.liebert.com