Académique Documents
Professionnel Documents
Culture Documents
Exercise 06
Installing the Adaptec ARO-1130U2
Install
Adaptec
ARO-1130U2
server.
server.
Exercise -06
Procedure:
6.1
6.2
An LED on the front panel of most computers is available to indicate non-SCSI hard
disk activity. If that LED is to light whenever there is activity on SCSI Channel A
(Controlled by ARO-1130U2), disconnect the LED cable from the motherboard and
connect it to the LED connector on the ARO-1130U2. If the LED has a two-position
cable, connect the cable to pins 1 and 2 of the LED connector.
If the ARO 1132oU2 supports multiple SCSI channels, and the LED is to
light whenever there is activity on any of those channels, refer to motherboard
documentation for instructions on setting the appropriate motherboard jumpers.
6.3
Once the ARO-1130U2 is installed in your system, refer to the documentation that
came with your computer and SCSI devices for specific instructions on setting up
your SCSI devices and connecting them to the SCSI connectors on the motherboard.
In most cases, it is not necessary to run the SCSI Select utility.
Page 2 of 2