Académique Documents
Professionnel Documents
Culture Documents
FiberOpticCable
OpticalFiber
FiberOptics
LEDOpticalFiber
EST MCQs
This is the Multiples Choice Questions Part 2 of the Series in Fiber Optics Communications as one of
the Communications Engineering topic. In Preparation for the ECE Board Exam make sure to expose
yourself and familiarize in each and every questions compiled here taken from various sources
including but not limited to past Board Examination Questions in Electronic System and Technologies,
Communications Books, Journals and other Communications References.
824likes
a. Computer networks
c. Closed circuit TV
d. Consumer TV
52. Total internal reection takes place if the light ray strikes the interface at an angle with what
relationship to the critical angle?
a. Less than
b. Grater than
c. Equal to
d. Zero
a. Refraction
b. Reection
c. Dispersion
d. Absorption
a. Single-mode step-index
b. Multimode graded-index
c. Single-mode graded-index
d. Multimode step-index
Pinoybix.org
LikePage
824likes
b. dB/km
a. 1 km
b. 2 km
c. 95 ft
d. 5500 ft
57. The upper pulse rate and information carrying capacity of a cable is limited by
a. Pulse shortening
b. Attenuation
c. Light leakage
d. Modal dispersion
a. Air
b. Glass
c. Diamond
d. Quartz
b. Kevlar
c. Cladding
d. Plastic insulation
60. The speed of light in plastic compared to the speed of light in air is
a. Slower
b. Faster
c. The same
Pinoybix.org
61. Which of the following is not a major benet of ber-optic cable?
LikePage
d. Lower cost
824likes
Bethefirstofyourfriendstolikethis
62. The main benet of light-wave communications over microwaves or any other communications
media is
a. Lower cost
b. Better security
c. Wider bandwidth
a. Infrafed
b. Ultraviolet
c. Visible color
d. X-rays
a. 0.8 to 1.0 nm
b. 400 to 750 nm
c. 200 to 660 nm
d. 700 to 1200 nm
a. 186,000 mi/h
b. 300 mi/h
c. 300,000 m/s
d. 300,000,000 m/s
a. Speed factor
b. Index of reection
c. Index of refraction
d. Dielectric constant
Pinoybix.org
LikePage
Bethefirstofyourfriendstolikethis
a. 0.7 um
b. 1.3 um
c. 1.5 um
d. 1.8 um
a. Single-mode step-index
b. Multimode step-index
c. Single-mode graded-index
d. Multimode graded-index
70. Which type of ber-optic cable is the best for very high speed data?
a. Single-mode step-index
b. Multimode step-index
c. Single-mode graded-index
d. Multimode graded-index
71. Which type of ber-optic cable has the least modal dispersion?
824likes
b. Multimode step-index
c. Single-mode graded-index
d. Multimode graded-index
a. Reection
b. Absorption
c. Scattering
d. Dispersion
a. 2.5 mi
b. 5 mi
Pinoybix.org
c. 8 mi
LikePage
d. 12.9 mi
824likes
Bethefirstofyourfriendstolikethis
74. A ber-optic cable has a loss of 15 dB/km. The attenuation in a cable, 100 ft long is
a. 4.57 dB
b. 9.3 dB
c. 24 dB
d. 49.2 dB
75. Fiber-optic cables with attenuations of 1.8, 3.4, 5.9, and 18 dB are linked together. The total loss is
a. 7.5 dB
b. 19.8 dB
c. 29.1 dB
d. 650 dB
76. Which light emitter is preferred for high speed data in a ber-optic system
a. Incandescent
b. LED
c. Neon
d. Laser
a. Visible
b. Infrared
c. Ultraviolet
d. X-ray
a. Forward bias
b. Reverse bias
c. Neither A or B
d. Either A or B
a. Pure
b. Intense
c. Coherent
d. Monochromatic
a. Pure
b. White
c. Coherent
d. Monochromatic
Pinoybix.org
LikePage
Bethefirstofyourfriendstolikethis
a. PIN photodiode
b. Photovoltaic diode
c. Photodiode
d. Avalanche photodiode
a. PIN photodiode
b. Photovoltaic diode
c. Phototransistor
d. Avalanche photodiode
a. Forward bias
b. Reverse bias
c. Neither A or B
824likes
d. Either A or B
84. The product of the bit rate and distance of a ber-optic system is 2 Gbits km/s. What is the
maximum rate at 5 km?
a. 100 Mbits/s
b. 200 Mbits/s
c. 400 Mbits/s
d. 1000 Gbits/s
a. 3 repeaters
b. 8 repeaters
c. 11 repeaters
Pinoybix.org
d. 20 repeaters
LikePage
824likes
b. Strong glass
d. Powerful regenerators
87. What is used to block light from a laser and let other light through
a. Neutral density
b. Color
c. Interference
d. Spatial
a. Spontaneous emission
d. Monochromatic
a. Light propagation
c. Drilling holes
d. Holography
90. The ultrapure glass used to manufacture optical bers is approximately ___pure
a. 99.9 %
b. 99.99 %
c. 99.999 %
d. 99.9999 %
a. Plastic-clad-silica
b. Polyethylene-clad-silica
d. Personal communication
Pinoybix.org
92. How many longitudinal modes can fall within a lasers gain bandwidth?
LikePage
a. 2
b. 5
c. 9
824likes
Bethefirstofyourfriendstolikethis
93. _________ is the result of photons of light that are absorbed by the atoms of the glass core
molecules
b. Ultraviolet absorption
c. Infrared absorption
d. Absorption loss
a. Suppressed-clad-silicon
b. Silicon base-class-silica
c. Silica-clad-silica
d. Serial-clad-silicon
a. 1960
b. 1962
c. 1963
d. 1964
96. What parameter of light detector determines the range or system length that can be achieved for a
given wavelength?
a. Transit time
b. Spectral response
c. Dark current
d. Responsitivity
d. Its imperfection
Pinoybix.org
a. Ampere/volt
b. Ampere/watt
c. Watt/ampere
d. Volts/ampere
LikePage
824likes
Bethefirstofyourfriendstolikethis
a. Responsitivity
b. Spectral response
c. Transmit time
d. Dispersion
100. What is the typical wavelength of light emitted from epitaxially grown LEDs?
a. 840 nm
b. 490 nm
c. 480 nm
d. 940 nm
Pinoybix.org
Pinoybix.org
LikePage
LikePage
824likes
824likes
Bethefirstofyourfriendstolikethis
Labels:
Newer Post
(http://www.pinoybix.org/2014/10/answers-inoptical-ber-communications-part2.html)
POST A COMMENT
Older Post
(http://www.pinoybix.org/2014/10/answers-inoptical-ber-communications-part1.html)
disqus
blogger