0 évaluation0% ont trouvé ce document utile (0 vote)
96 vues1 page
The document provides repair tips for a DCX2496 device, including possible causes and solutions for several common problems:
1) Crackling or cutting audio could be caused by poor connections at ribbon cables, which can be fixed by replacing the ribbon cable and resoldering the connections.
2) A device that does not function sometimes may have dry solder joints, usually on the bottom of the PCB, which requires resoldering the PCB.
3) A device that does not boot after powering on could be caused by a bad connection to the EPROM or faulty EPROM; checking and reseating the EPROM or replacing it may fix the problem.
The document provides repair tips for a DCX2496 device, including possible causes and solutions for several common problems:
1) Crackling or cutting audio could be caused by poor connections at ribbon cables, which can be fixed by replacing the ribbon cable and resoldering the connections.
2) A device that does not function sometimes may have dry solder joints, usually on the bottom of the PCB, which requires resoldering the PCB.
3) A device that does not boot after powering on could be caused by a bad connection to the EPROM or faulty EPROM; checking and reseating the EPROM or replacing it may fix the problem.
The document provides repair tips for a DCX2496 device, including possible causes and solutions for several common problems:
1) Crackling or cutting audio could be caused by poor connections at ribbon cables, which can be fixed by replacing the ribbon cable and resoldering the connections.
2) A device that does not function sometimes may have dry solder joints, usually on the bottom of the PCB, which requires resoldering the PCB.
3) A device that does not boot after powering on could be caused by a bad connection to the EPROM or faulty EPROM; checking and reseating the EPROM or replacing it may fix the problem.
074-00040-70720 X2 - 20 Pole 70mm 074-00041-80726 X13 - 26 Pole 180mm
replace ribbon cable and re-solder connections
sometimes no function
dry solder joint (in most cases bottom side)
PCB needs to be resoldered
Bad contact to EPROM or faulty EPROM
check that EPROM is correctly seated, replace faulty EPROM, update with unit does not boot after power on, not possible to reload OS (012-14630-20140) most recent version of OS (V1.40) The 26 poles push-on terminal strip X13 and the 20poles push-The contact strips should be insulated with spacers interruptions of the audio signal. on terminal strip X14 on the IN/OUT board, can be short circuit caused by plugging the XLR jacks ( IN and OUT) into the rear board and thus comes to interruptions of the audio signal.