F09 Power leakage of some kind. Heat, exposure, AC or power supply.
F23 Toner motor
Toner density adjustment problem. This means machine is undertoned. To repair, replace developer and enter "47" mode. Press 51. Press print. Allow the machine to F26 cycle until it stops. Some feel that you should disconnect the toner motor first. This code happens probably because either machine wasn't set up properly, or the customer kept on using the machine with the toner light on. F28 Corona problem. Could be any corona. Must reset with "25: mode, "P45" set to "0" F34 High fuser temperature* F35 Low fuser temperature* F36 Low fuser temperature* F41 Scan home F42 Scan home F43 Exposure lamp F45 Lens problem F54 Fan motor F60 ADF to main board communication problem F67 ADF encoder F77 Sorter gate F88 AE adjustment problem J11 Feed jam J12 Feed jam J13 Feed jam J16 Jam inside J31 Exit jam J32 Exit jam J61 ADF jam J62 ADF jam J63 ADF exit jam J72 Sorter jam P20 Drum unit or toner level connection problem P25
300 copies have been run since toner light came on. Depending on how 25 mode, code 92 is set, machine may not work at all.
P26 Must adjust TDS????in 47 mode
P64 ADF & operator are confused P68 ADF feed problem
P69 ADF feed problem
P71 Sorter interlock P81 Key counter not installed