Académique Documents
Professionnel Documents
Culture Documents
Gteborg, Sweden
Service Bulletin
Trucks
D
Date
Group
No.
Release
Page
10.07
214
98
01
1(4)
T2024989
Contents
Valves and unit injectors, adjust page 2
20124713
ENG26101.ihval
English
Printed in Sweden
Date
Group
No.
Release
10.07
214
98
01
Page
2(4)
Service Procedures
21414-3
Valves and unit injectors, adjust
Valve cover removed
Note: Because the illustrations in the service literature are used for different engine
variants, there may be differences in some of the components.
The essential information in the illustrations is, however, always correct.
WARNING
The parking brake must be applied when cranking the
engine with the starter motor. Remove the control unit
fuse F40 to avoid unintentional starting of the engine
and check that the vehicle is not in gear.
Alternative 1: Remove the plug on the underside of the
flywheel casing and fit cranking tool 88800014.
Alternative 2: Remove the fuses for the engine electronic
control unit and connect equipment to crank the engine
using the starter motor.
88800014
T2022960
2
Camshaft markings for adjusting valves and unit
injectors:
Date
Group
No.
Release
10.07
214
98
01
Page
3(4)
T2022961
4
Adjust the correct valve clearance on the inlet valves. Use
a tool to hold adjusting screw (B) still and tighten locking
nut (A) with an open spanner. See Function group 20,
Information type Specifications, Specifications.
Re-measure the valve clearance.
Note: Make a mark with a marker pen when an
adjustment has been completed, to keep track of the
valves and unit injectors which have been adjusted.
T2024989
Date
Group
No.
Release
10.07
214
98
01
Page
4(4)
T2024990
T2024991
7
Rotate the engine to the next marking on the camshaft for
adjusting the exhaust valves.
8
Adjust the remaining valves and unit injectors in the
same way.