Académique Documents
Professionnel Documents
Culture Documents
MISCELLANEOUS
COMPONENTS
COMPONENTS
VEHICLE SPEED SENSOR
REED S/W TYPE
The sensor is built into the speedometer and converts the transaxle
speedometer driven gear revolutions (vehicle speed) to pulse signals and
sends them to the engine control module.
HALL IC TYPE
The sensor is built on the transaxle differential gear and converts
the transaxle gear revolutions into pulse signals
VEHICLE SPEED SENSOR
CIRCUIT
ECM
CONTROL
RELAY
5V
SIGNAL
output voltage
signals for each rotation of the
5V
speedometer driven gear.
Therefore, the sensor output
frequency increases in
proportion to the vehicle speed. 1 revolution
Output Frequency
Vehicle Speed Km/h
VEHICLE SPEED SENSOR
WAVEFORM - SUDDEN ACCELERATION
COMMENTS:
APPLICABLE
VEHICLE :
All Model
IG. S/W & T/A RANGE S/W
IG. S/W & T/A S/W
When the ignition switch is set in the ST position, the battery
voltage is applied through the ignition switch and inhibitor switch
to the ECM. If the selector lever is not in the P or N positions, the
battery voltage will not reach the ECM. Based on this signal, the
ECM determines the automatic transaxle load and drives the idle
speed actuator to maintain optimum idle speed.
IG. S/W & T/A RANGE S/W
CIRCUIT
TO TCM
IGNITION
DRIVE S/W
POSITION
S/W
ECM GROUND
ECM GROUND
Most sensors ground through the ECM.
If ECM ground does not ground, most sensors does not operate.
Check the ground of the ECM.
The A/C switch applies the battery voltage to the ECM when the
air conditioning is turned ON. When the air conditioning ON
signal is detected, the ECM drives the ISC Actuator and turns the
ignition power transistor ON. Then, the A/C power coil is
energized to turn the relay switch ON, which activates the air
compressor magnetic clutch.
A/C S/W
A/C RELAY
A/C SWITCH & RELAY
IG. S/W
FUSIBLE LINK
A/C S/W
A/C THERMO
RELAY S/W
PRESSURE
S/W
COMPRESSOR
ECM
POWER STEERING S/W
POWER STEERING S/W
The power steering oil pressure s/w
senses the power steering load into
high/low voltage and inputs it to the ECM.
The ECM then controls the idle speed
control motor based on this signal.
POWER
STEERING
S/W
POWER STEERING S/W
APPLICABLE VEHICLE
SONATA ALL MODEL EXCEPT V6 ENGINE
ELANTRA BEFORE 95MY
EXCEL
NON APPLICABLE VEHICLE
SCOUPE, ACCENT, ELANTRA 96MY,
Alpha and beta engines do not require a power steering
s/w.
MFI CONTROL RELAY
CONTROL
ECM RELAY
MFI CONTROL RELAY
CONTROL RELAY - MELCO
When the ignition s/w is turned
ON, battery voltage is applied
IGNITION S/W
from the ignition s/w to the
ECM. This turns the ignition
power transistor ON and
energizes the MFI control relay
coil. This turns the MFI control
relay s/w ON and power is
supplied from the battery to the
ECM through the MFI control
relay s/w.
MFI CONTROL RELAY
WAVEFORM - SIEMENS
COMMENTS:
CONTROL RELAY
IGNITION S/W