Académique Documents
Professionnel Documents
Culture Documents
Digital Wallcollection
General
> We recommend applying the Vescom primer/sealer using a square brush.
> The wallcovering will be easier to remove after a length of time by using an
undiluted Vescom primer/sealer.
Vescom adhesive
Only use Vescom adhesive to obtain the best results.
We recommend using Vescom 2000 adhesive for the Digital Wallcollection.
Stir the Vescom adhesives appropriately before use. Vescom 2000 adhesive may be
diluted by at most 6% depending on the conditions such as, for example, the
temperature and/or the state of the substrate and the wallcovering type. Always seal
the adhesive packaging correctly. Shelf life: 9 months.
Tools
Use a square brush in corners, the ceiling and the skirting and use a short-pile synthetic
sheepskin roller for wall surfaces. Clean tools using water.
Adhesive application
Vinyl qualities with a non-woven rug: 5-6 m2/kg.
Vescom primer/sealer
Dilution Consumptio
n
Normally absorbing substrates 1 part of primer/sealer and 10 m2/L
3 parts of water
Strongly absorbing substrates Undiluted 7 m2/L
The above consumption is indicative and will strongly depend on the substrate
conditions, temperature, air humidity and wallcovering type.
General processing
General: The wallcovering must be processed
in order. Follow the supplied drop plan.
Cut and separate the drops and remove the
white edges. Place the drops on the floor
overlapping each other. When the correct
position of the drops has been determined at
the top and bottom sides, stick crepe tape on
the overlap in-between the drops. Cut the crepe
tape carefully (fig. A). Use both halves of the
crepe tape as a guide to position the drops
correctly on the wall (fig. B).
Add a plumb line (using a black graphite pencil) in such a way that the material
overlaps the starting corner by 3 cm. Apply adhesive to the substrate (drop width 20
cm) using a short-pile synthetic sheepskin roller. Position drop no. 1 on to the wet
adhesive against the plumb line so that the material continues (i.e. overlaps) at the
ceiling, skirting and comer by a few centimetres. Next, smooth the material using the
smoother in the length direction of the drop on the wall so that the air in-between the
material and the substrate is completely removed.
The drop ends in the corner when it involves an inward corner. The material must be
stuck by at least 20 cm more when it involves an outward corner.
The Digital Wallcreator takes these conditions into account when determining the drop
plan.
Important
Delivery mistakes can be determined after having hung 3 drops. Should you find
defects, please contact your supplier. Later claims cannot be accepted. Technical and
other data in these instructions apply as from the date that these instructions have been
published and will remain in force until new instructions are published.
Maintenance
Consult the Vinyl wallcovering cleaning advice brochure for information on Vescom
Digital Wallcollection maintenance.
www.vescom.com