Académique Documents
Professionnel Documents
Culture Documents
Engineering FAQs
The recommended maximum hole sizes for anchor rods in base plates are given in the 13th Edition Manual Table 14-2. It is noted that these
hole sizes permit a reasonable tolerance for misalignment in setting the bolts and more precision in the adjustment of the base plate or
column to the correct centerlines. Note that these hole sizes are such that flame-cutting will often be required. An adequate washer (see
7.2.4) should be provided for each anchor rod. Because these hole sizes are recommended as maximum sizes, the use of smaller hole
sizes is often justified if anchor-rod groups are set accurately.
Enviar consulta
https://www.aisc.org/DynamicQuestion.aspx?Grpid=6&QueId=1840&ste=_Preview&id=... 12/09/2016