Académique Documents
Professionnel Documents
Culture Documents
MIC CHANNEL
Rechargerble Amplifier
GUITAR AMPLIFIER
MT-8RMASTER CHARGER
LOW/BATT POWER
DC
AC
0 10 0 10 HIGH LOW 0 10 0 10 0 10 0 10 0 10 0 10
RD:PROTECT
INPUT LEVEL REVERB INPUT LEVEL TREBLE MIDDLE BASS REVERB LEVEL GN:POWER ON
AC / DC MULTIPLE AMPLIFIER
MT-8R
CONTENTS
CONTENTS ------------------------------------------------------------------ 2
2
Read the Following Before operating the MT-8R
CAUTIONS
Do not break up who is not expert with technical knowledge about this unit.
If you consider internal inspection, maintenance, or repair is necessary, contact your local dealer.
Do not expose this equipment to moisture or high temperature and oscillation.
When disconnecting it from an AC outlet, Never pull the power cord. A damaged power cord will
cause fire and electrical shock hazard.
Do not touch the power plug with hands. It might cause electrical shock hazard.
OPERATION NOTES
The digital circuits of this unit may induce a slight noise if you set it up nearby radio and TV. If
noise occurs, relocate it at a proper place away from those electric appliances.
Using a cellular phone near this unit may cause the noise. If noise occurs, please use the cellular
phone away from the unit.
Do not set faders to maximum. It may cause the oscillation that can damage the speaker.
3
The model MT-8R Multiple Amplifier with Spring Reverb, combines many years of design engineering and
manufacturing experience into a rugged reliable multipurpose amplifier. It has been designed to achieve the
finest sound available complemented by a user-friendly control panel for maximum versatility and trouble free
operation. To familiarize yourself to your new amplifier please rear over this owners manual at your
convenience.
MIC CHANNEL
Rechargerble Amplifier
GUITAR AMPLIFIER
MT-8RMASTER CHARGER
LOW/BATT POWER
17
DC
AC
0 10 0 10 HIGH LOW 0 10 0 10 0 10 0 10 0 10 0 10
INPUT LEVEL REVERB INPUT LEVEL TREBLE MIDDLE BASS REVERB LEVEL
RD:PROTECT
GN:POWER ON
16
13 14 15
MIC
GUITAR
MIC CHANNEL
1. INPUT Electronically balanced inputs accept a standard XLR male connector.
2. LEVEL Set the input level for talc MIC-1 CHANNEL with this control.
3. REVERB Adjusts the amount of reverberated signal mixed with the original dry signal.
MASTER
11. LEVEL Set the main output level by this control.
POWER SECTION
12. CHARGER LED ON : When internal rechargeable battery is charging.
OFF : When charging is finished.
13. LOW / BATT ON : not using battery for long time or battery is weak Amp doesnt work and
disconnect.
OFF : Battery is good condition.
14. DC LED ON : When amplifier is working with internal battery.
15. AC LED ON : When amplifier is working with external AC power.
16. POWER LED In normal condition : When power switch is ON, it will be RED and then it goes to
green.
In abnormal condition : RED illumination stay long time.
17.POWER This switch turns the AC power ON and OFF.
4
REAR PANEL FUNCTIONS
HEADPHONE CD PLAYER
18
PRIMARY FUSE
CAUTION !! WARNING !!
TO REDUCE THE RISK OF ELECTRICAL SHOCK, DO TO REDUCE THE RISK OF FIRE OR ELECTRIC SHOCK,
NOT REMOVE COVER. NO USER SERVICEABLE PARTS DO NOT EXPOSE EQUIPMENT TO RAIN OR MOISTURE.
INSIDE. REFER SERVICING TO QUALIFIED SERVICE IMPROPER SPEAKER CONNECTIONS MAY DAMAGE
PERSONNEL. TAMPERING WITH THIS UNIT MAY VOID THIS UNIT AND/OR SPEAKERS. IMPROPER OPERATION
MANUFACTURER'S WARRANTY. MAY VOID MANUFACTURER'S WARRANTY.
0 10 0 10
POWER CONSUMPTION MADE IN KOREA HEAD ABOVE 4 Ohm RIGHT LEFT
WATTS PHONE EXT SPEAKER LINE TONE LEVEL
S/NO
19 20 21 22 23 24 25
18. FUSE HOLDER When occur problem on this appliance, the fuse will be cut off power to prevent from
a problem. To replace, use standard fuse as specified on this appliance.
19. POWER CORD This power cord is heavy-duty grounded and three wired and is suitable AC115~230V
50~60Hz.
20. HEAD PHONE This jack provides an output standard stereo or mono headphone for private
listening. This jack can also be used as an unbalanced line output by using either a
1/4 inch phone plug connection.
21. EXTERNAL SPEAKER
This jack provides an output to an external speaker enclosure. The enclosure must
have a minimum impedance of 8. Using of this jack will automatically make the
internal speaker disable. DO NOT PLUG HEAD PHONE IN HERE.
22. LINE OUT Filtered output connection direct to a recording or PA mixing desk.
CD SECTION
23. TONE Adjusting bass & treble sound of CD player signal using by this control.
24. LEVEL Set the output volume for the CD player with this control.
25. INPUT The CD player output connection for instrument.
5
SPECIFICATIONS
HIGH EXTERNAL
HIGH
LEVEL TREBLE MIDDLE BASS SPEAKER
REVERB REVERB
LOW
LOW
LEVEL
REVERB 12" 50W
MAIN
KEYBOARD CHANNEL REVERB
REVERB
CHARGER
R
LEVEL
BATT AC
HEADPHONE
L
R
LEVEL TONE
6
LEEM LIMITED WARRANTY
This warranty is for LEEM product only. Any service claims resulting form other brands
used in conjunction with LEEM products will not be allowed or honored.
All transportation charges involved with sending and returning the unit to and
from the warranty center is solely the responsibility of the purchaser. LEEM
assumes no liabilities for damages incurred in transit to or from service center.
If return is to be made to LEEM, customer must first obtain return Authorization by mail.
After receipt of return Authorization, owner must ship product whit copy of original sales
receipt, and a detailed description of the problem. Please include your return
Authorization number on all correspondence. Repaired products will be returned freight
collect. LEEM will, at its option, or replace defective parts or products.
Neither LEEM, nor Authorized LEEM Dealers, nor Authorized LEEM Service Centers are
liable for any incidental or consequential damages resulting from any defect in or failure
of LEEM products.
This warranty gives the original owner of LEEM products specific legal rights, and you
may also have specific rights that vary from state to state. This warranty is expressly in
lieu of all other agreements and warranties, expressed or implied, except as may be
otherwise required by law.
7
LEEM PRODUCTS CO., LTD
.
HEAD OFFICE
118B-6L, NAMDONG INDUSTRIAL AREA, 688-14,
KOJAN-DONG, NAMDONG-KU, INCHON, KOREA
TEL : (032) 816-7100~6
FAX : (032) 816-7108~9
E-mail : leem@leem.co.kr
Homepage : www.leem.co.kr