Académique Documents
Professionnel Documents
Culture Documents
RA41204EN15GLA1 1
LTE FDD Air Interface overheads
RA41204EN15GLA1 2
LTE FDD Air Interface overheads
RA41204EN15GLA1 5
LTE FDD Air Interface overheads
RA41204EN15GLA1 6
LTE FDD Air Interface overheads
RA41204EN15GLA1 7
LTE FDD Air Interface overheads
RA41204EN15GLA1 8
LTE FDD Air Interface overheads
RA41204EN15GLA1 9
LTE FDD Air Interface overheads
RA41204EN15GLA1 10
LTE FDD Air Interface overheads
RA41204EN15GLA1 11
LTE FDD Air Interface overheads
RA41204EN15GLA1 12
LTE FDD Air Interface overheads
RA41204EN15GLA1 13
LTE FDD Air Interface overheads
RA41204EN15GLA1 14
LTE FDD Air Interface overheads
Effect of the overhead reduction can be also obtained by extending the PRS repetition period (PRS
signals appears in longer time intervals). On the other hand, PRS signaling overhead can be
increased by increasing the number of the DL subframes that are used for PRS signals (it consumes
more resources in time domain within one PRS signal repetition).
RA41204EN15GLA1 15
LTE FDD Air Interface overheads
RA41204EN15GLA1 16
LTE FDD Air Interface overheads
RA41204EN15GLA1 17
LTE FDD Air Interface overheads
RA41204EN15GLA1 18
LTE FDD Air Interface overheads
RA41204EN15GLA1 19
LTE FDD Air Interface overheads
RA41204EN15GLA1 20
LTE FDD Air Interface overheads
RA41204EN15GLA1 21
LTE FDD Air Interface overheads
RA41204EN15GLA1 22
LTE FDD Air Interface overheads
RA41204EN15GLA1 23
LTE FDD Air Interface overheads
System overhead
It is recommended to assume 3 OFDM symbols per TTI for PDCCH to account for
maximized controlling region capacity. The cell-specific Reference Signal overhead
depends on the number of active antenna ports (it is two times higher for dimensioning
with transmit diversity at the cell-edge). These are the two most important factors
impacting dimensioning and capacity results. The rest of DL PHY channels and signals
can be neglected.
For uplink control channel (PUCCH), it is recommended to assume 1 PRB (1.4 MHz), 2 (3
and 5 MHz), 4 (10 MHz), 6 (15 MHz), 8 (20 MHz).
PRACH density (number of PRACH resources per radio frame) can be set to 1, which
means that one PRACH resource (consisting of 6 PRBs) is reserved per every radio
frame. It obviously depends on the subscriber profile (that is service usage, mobility,
etc.).
RA41204EN15GLA1 24
LTE FDD Air Interface overheads
RA41204EN15GLA1 25
LTE FDD Air Interface overheads
RA41204EN15GLA1 26