Académique Documents
Professionnel Documents
Culture Documents
1 Laden
2 Empty
3 Idle
4 Engine of
5 Of
on change
rature alert
(wires A04 & A05) related fault : the output current exceeds 1400 mA or/and the output plus line is shorted to
(wires A02 & A03) related fault : the output current exceeds 1400 mA or/and the output plus line is shorted to
sor 2 too low for command.
sor 1 too low for command.
ange invalid
cessing cancelled
d. Need to use backup statistics file.
AT DIRECTION SELECT SIGNAL
d 1 Temperature - Voltage below normal or shorted low (SPN 105 FMI 4)
Catalyst Tank Controller - Data erratic, intermittent, or incorrect (SPN 3360 FMI 2)
ntrolling Device for Engine Control - Data erratic, intermittent, or incorrect (SPN 1483 FMI 2)
on - Data erratic, intermittent, or incorrect (SPN 51 FMI 2)
a valid but below normal operational range, moderately severe level (SPN 98 FMI 18)
eature - Data erratic, intermittent, or incorrect (SPN 1632 FMI 2)
Data valid but below normal operational range (SPN 111 FMI 1)
d 1 Temperature - Data valid but above normal operational range (SPN 105 FMI 0)
nge invalid
Catalyst Tank Level - Data valid but below normal operational range, least severe level (SPN 1761 FMI 17)
ressure - Data valid but below normal operational range, moderately severe level (SPN 94 FMI 18)
Relay - Current below normal or open circuit (SPN 677 FMI 5)
G_TABLE_INDEX
rature - Data valid but above normal operational range, moderately severe level (SPN 110 FMI 16)
rature - Data valid but above normal operational range (SPN 110 FMI 0)
el Exhaust Fluid Dosing Unit - Bad intelligent device or component (SPN 3361 FMI 12)
r 1 - Data valid but above normal operational range (SPN 97 FMI 0)
39 - Special instructions (SPN 743 FMI 14)
Data valid but below normal operational range (SPN 100 FMI 1)
sor - Abnormal update rate (SPN 91 FMI 9)
VERTER OUTPUT
ducement Level 5 (SPN 5246 FMI 0)
on - Out of calibration (SPN 51 FMI 13)
Data valid but below normal operational range, moderately severe level (SPN 100 FMI 18)
mal frequency, pulse width, or pending (SPN 190 FMI 8)
ducement Level 1 or 2 (SPN 5246 FMI 16)
d #1 Pressure - Data valid but above normal operational range (SPN 102 FMI 0)
e 1 - Voltage below normal or shorted low (SPN 175 FMI 4)
e 1 - Data valid but above normal operational range, moderately severe level (SPN 175 FMI 16)
e 1 - Data valid but above normal operational range (SPN 175 FMI 0)
sor - Data erratic, intermittent, or incorrect (SPN 91 FMI 2)
a erratic, intermittent, or incorrect (SPN 898 FMI 2)
39 - Abnormal update rate (SPN 743 FMI 9)
sor - Failure mode not identifiable (SPN 91 FMI 11)
er #02 - Voltage above normal or shorted high (SPN 652 FMI 3)
er #03 - Voltage above normal or shorted high (SPN 653 FMI 3)
er #04 - Voltage above normal or shorted high (SPN 654 FMI 3)
er #05 - Voltage above normal or shorted high (SPN 655 FMI 3)
ol Pressure Regulator - Special instructions (SPN 679 FMI 14)
ZERO DOESNT FIT TO OTHER SPEED SIGNALS
d #1 Pressure - Data valid but above normal operational range, moderately severe level (SPN 102 FMI 16)
ent below normal or open circuit (SPN 98 FMI 5)
ng Rail 1 Pressure - Special instructions (SPN 157 FMI 14)
Current below normal or open circuit (SPN 153 FMI 5)
NPUT TORQUE OVERLOAD
D AT RETARDER / TORQUECONVERTER TEMPERATURE SENSOR INPUT
wire A29) related fault : analog input is not connected.
d #1 Pressure - Data erratic, intermittent, or incorrect (SPN 102 FMI 2)
Data erratic, intermittent, or incorrect (SPN 108 FMI 2)
) - Abnormal rate of change (SPN 1675 FMI 10)
ressure - Voltage above normal or shorted high (SPN 94 FMI 3)
response during calibration.
G_STATREG_INDEX
ol Pressure Regulator - Data valid but above normal operational range (SPN 679 FMI 0)
ol Pressure Regulator - Failure mode not identifiable (SPN 679 FMI 11)
VOLTAGE OR O.C. AT TURBINE SPEED INPUT
VOLTAGE OR O.C. AT INTERNAL SPEED INPUT
Relay - Voltage below normal or shorted low (SPN 677 FMI 4)
AT OUTPUT SPEED INPUT
TCH CONTROL
- Voltage above normal or shorted high (SPN 354 FMI 3)
Relay - Data erratic, intermittent, or incorrect (SPN 677 FMI 2)
or 1 Control Command - Mechanical system not responding properly (SPN 3464 FMI 7)
ntial (Voltage) - Data erratic, intermittent, or incorrect (SPN 167 FMI 2)
r 1 - Data valid but above normal operational range, least severe level (SPN 97 FMI 15)
VOLTAGE OR O.C. AT OUTPUT SPEED INPUT
a valid but below normal operational range (SPN 98 FMI 1)
1 Wastegate Drive - Voltage below normal or shorted low (SPN 1188 FMI 4)
1 Wastegate Drive - Current below normal or open circuit (SPN 1188 FMI 5)
wer Input 1 - Data valid but below normal operational range (SPN 168 FMI 1)
- Data erratic, intermittent, or incorrect (SPN 158 FMI 2)
Voltage below normal or shorted low (SPN 111 FMI 4)
d 1 Temperature - Data valid but above normal operational range, moderately severe level (SPN 105 FMI 16)
ON_MONO
T_FEATURE_ASSIGNMENT
Data erratic, intermittent, or incorrect (SPN 111 FMI 2)
Voltage below normal or shorted low (SPN 108 FMI 4)
d #1 Pressure - Voltage below normal or shorted low (SPN 102 FMI 4)
Voltage below normal or shorted low (SPN 100 FMI 4)
rature - Voltage above normal or shorted high (SPN 110 FMI 3)
e 1 - Voltage above normal or shorted high (SPN 175 FMI 3)
el Exhaust Fluid Dosing Valve - Bad intelligent device or component (SPN 5394 FMI 12)
wire B02) related fault: analog input is shorted to ground.
em related to the internal RAM (in CPU).
ion pattern
during touch pressure calibration. Too much drag
down Switch - Failure mode not identifiable (SPN 970 FMI 11)
e 1 - Current below normal or open circuit (SPN 175 FMI 5)
- Data valid but below normal operational range, moderately severe level (SPN 158 FMI 18)
is flashed into the APC200.
sor 4 too high for command.
sor 2 too high for command.
) - Voltage above normal or shorted high (SPN 2898 FMI 3)
bnormal update rate (SPN 1231 FMI 9)
alid but above normal operational range, moderately severe level (SPN 190 FMI 16)
ng Rail 1 Pressure - Data valid but below normal operational range, moderately severe level (SPN 157 FMI 18)
ng Rail 1 Pressure - Data valid but below normal operational range (SPN 157 FMI 1)
down Switch - Voltage below normal or shorted low (SPN 970 FMI 4)
uring calibration
wire A28) related fault : analog input is shorted to ground.
Data valid but above normal operational range (SPN 153 FMI 0)
or 1 Control Command - Voltage above normal or shorted high (SPN 3464 FMI 3)
Current below normal or open circuit (SPN 100 FMI 5)
VOLTAGE OR O.C. AT ENGINE SPEED INPUT
ol Pressure Regulator - Current above normal or grounded circuit (SPN 679 FMI 6)
r 1 - Voltage above normal or shorted high (SPN 97 FMI 3)
ure - Current below normal or open circuit (SPN 164 FMI 5)
or 1 Control Command - Current below normal or open circuit (SPN 3464 FMI 5)
et NOx - Data erratic, intermittent, or incorrect (SPN 3226 FMI 2)
on - Mechanical system not responding properly (SPN 51 FMI 7)
on - Bad intelligent device or component (SPN 51 FMI 12)
changed
1st Clutch Pressure: Data Valid but Below Normal Operational Range - Most Severe
3rd Clutch Pressure: Data Valid but Below Normal Operational Range - Most Severe
e counter reset
LH solenoid
RH solenoid
wn LH solenoid
wn RH solenoid
LH solenoid
RH solenoid
wn LH solenoid
wn RH solenoid
p LH solenoid
p RH solenoid
own LH solenoid
own RH solenoid
p LH solenoid
p RH solenoid
own LH solenoid
own RH solenoid
piggy back clamped
piggy back seated
piggy back unclamped
ht piggy back clamped
ht piggy back seated
rror (>85 C)
stlocks solenoid
twistlocks solenoid
istlocks solenoid
twistlocks solenoid
wistlocks solenoid
wistlocks solenoid
H twistlocks solenoid
H twistlocks solenoid
p solenoid
up solenoid
p solenoid
alve activation
valve activation
spreader seated
twistlocks locked
twistlocks unlocked
ht spreader seated
ht twistlocks locked
ht twistlocks unlocked
C2 (ANIC2): Data Valid but Above Normal Operational Range - Most Severe
nput Function: Drum speed: Current Below Normal, or Open Circuit
ecirculation Temperature - Current below normal or open circuit (SPN 412 FMI 5)
nction: Transmission Sump Temperature: Voltage Above Normal, or Shorted To High Source
188 FMI 4)
188 FMI 5)
N 168 FMI 1)
sure calibration
N 679 FMI 5)
erly (SPN 679 FMI 7)
PN 442 FMI 5)
mory conflict
g properly (SPN 3361 FMI 7)
SOR INPUT
ational range, least severe level (SPN 3364 FMI 17)
east Severe
Most Severe
791 FMI 9)
mal operational range (SPN 4374 FMI 1)
code (maximum number of retries reached during P2mA for the peak to peak pressure)
Normal, or Shorted To High Source
Above Normal Operational Range - Least Severe
ost Severe
Range - Most Severe
code (During P2mA routine a pressure drop of more than 1 bar is detected)
touch pressure calibration.
ed low (SPN 2791 FMI 4)
N 173 FMI 0)
oderately severe level (SPN 173 FMI 16)
ted high (SPN 411 FMI 3)
N 102 FMI 7)
Most Severe
nge, moderately severe level (SPN 157 FMI 16)
1188 FMI 3)
circuit (SPN 2791 FMI 5)
High Source
Most Severe
N 4334 FMI 7)
Message Speed (km/h)
Signal 'sw_safety_override' warn 0
Lift of C20956 filtered at 1485852309479. Container counter not incremented.
Signal 'sw_safety_override' warn 0
Signal 'sw_safety_override' warn 0
Invalid engine hours change over possible gap. From 270.95 (1486200706096) to 270.75 (148621086
Signal 'sw_safety_override' warn 0
Engine Oil Level - Data valid b 0
Invalid engine hours change over possible gap. From 337.20 (1486958489030) to 336.40 (148696895
A cumulative counter value decreased from 2578.00 to 2570.00.
Engine Fuel Delivery Pressure - 0
Signal 'sw_safety_override' warn 0
Engine Oil Level - Data valid b 0
Engine Oil Level - Data valid b 0
Signal 'sw_safety_override' warn 0
Lift of C20956 filtered at 1487514772269. Container counter not incremented.
Engine Oil Level - Data valid b 0
Engine Oil Level - Data valid b 0
Signal 'sw_safety_override' warn 0
Engine Oil Level - Data valid b 0
Signal 'sw_safety_override' warn 0
Signal 'sw_safety_override' warn 0
Signal 'sw_safety_override' warn 0
Signal 'sw_safety_override' warn 0
Software version of modem 000592 has changed from 4.0.3 to 4.1.1.
Engine of state inferred at 1488420000000
e peak to peak pressure)
is detected)
Longitude Latitude
103.0817871094 -1.0001900196
counter not incremented.
103.0818023682 -1.0001900196
103.0779037476 -1.0022200346
270.95 (1486200706096) to 270.75 (1486210868541). Delta -0.20 over 2.82 hours.
103.0777511597 -1.0020699501
103.0786132812 -1.0008900166
counter not incremented.
103.0780029297 -1.002589941
103.0777282715 -1.001940012
103.0779190063 -1.0027799606
103.0779571533 -1.0025600195
103.0779724121 -1.0025600195
103.0779724121 -1.0025099516
m 4.0.3 to 4.1.1.