0 évaluation0% ont trouvé ce document utile (0 vote)
11 vues1 page
This document provides the design calculations for a 120x121x12mm thick galvanized mild steel angle that is connected to a U-channel. It references the relevant building codes and standards for structural steel design in Hong Kong. The material properties of the grade 275 structural steel and 220 N/mm2 fillet welds to be used are defined, including modulus of elasticity, design strength, and density.
This document provides the design calculations for a 120x121x12mm thick galvanized mild steel angle that is connected to a U-channel. It references the relevant building codes and standards for structural steel design in Hong Kong. The material properties of the grade 275 structural steel and 220 N/mm2 fillet welds to be used are defined, including modulus of elasticity, design strength, and density.
This document provides the design calculations for a 120x121x12mm thick galvanized mild steel angle that is connected to a U-channel. It references the relevant building codes and standards for structural steel design in Hong Kong. The material properties of the grade 275 structural steel and 220 N/mm2 fillet welds to be used are defined, including modulus of elasticity, design strength, and density.
STEEL'S WORK LTD No. Part of Structure 31/3/2017 Design of 10mm Thk. GMS Angle Ref. Calculations 1.0 INTRODUCTION This submission cover the design calculation of 120x121x12mm Thk. GMS Angle , which connected to the U-channel.
2.0 DESIGN STANDARDS AND REFERENCES
2.1 Building (Construction) Regulations, 1990. 2.2 Code of Practice for Dead and Imposed Loads - 2011 2.3 Code of Practice for The Structural Use of Steel, Hong Kong - 2011
3.0 MATERIAL PROPERTIES :
3.1 Structural Steel
All steel shall be grade 275 complied with BS EN Standard
- For hot rolled products : adopt grade 275 in compliance with BS EN 10025 - For hot finished hollow sections : adopt grade 275J0 in compliance with BS EN 10210
Modulus of Elasticity Es = 205000 N/mm2
Design Strength (for t < 16mm) py = 275 N/mm2
Density s = 7850 kg/m3
3.2 Weld
For the Use of Weld (Fillet Weld)
Design strength of S275 fillet weld pw = 220 N/mm2