0 évaluation0% ont trouvé ce document utile (0 vote)
19 vues1 page
This document provides the design calculations for a 10mm thick galvanized mild steel angle that is connected to a U-channel. It references the relevant building codes and standards for structural steel design. It lists the material properties for the S275 grade structural steel, including its modulus of elasticity, design strength, and density. It also provides the design strength for S275 fillet welds.
This document provides the design calculations for a 10mm thick galvanized mild steel angle that is connected to a U-channel. It references the relevant building codes and standards for structural steel design. It lists the material properties for the S275 grade structural steel, including its modulus of elasticity, design strength, and density. It also provides the design strength for S275 fillet welds.
This document provides the design calculations for a 10mm thick galvanized mild steel angle that is connected to a U-channel. It references the relevant building codes and standards for structural steel design. It lists the material properties for the S275 grade structural steel, including its modulus of elasticity, design strength, and density. It also provides the design strength for S275 fillet welds.
STEEL'S WORK LTD No. Part of Structure 31/3/2017 Design of 10mm Thk. GMS Angle Ref. Calculations 1.0 INTRODUCTION This submission cover the design calculation of 10mm Thk. GMS Angle , which connected to the U-channel.
2.0 DESIGN STANDARDS AND REFERENCES
2.1 Building (Construction) Regulations, 1990. 2.2 Code of Practice for Dead and Imposed Loads - 2011 2.3 Code of Practice for The Structural Use of Steel, Hong Kong - 2011
3.0 MATERIAL PROPERTIES :
3.1 Structural Steel
All steel shall be grade 275 complied with BS EN Standard
- For hot rolled products : adopt grade 275 in compliance with BS EN 10025 - For hot finished hollow sections : adopt grade 275J0 in compliance with BS EN 10210
Modulus of Elasticity Es = 205000 N/mm2
Design Strength (for t < 16mm) py = 275 N/mm2
Density s = 7850 kg/m3
3.2 Weld
For the Use of Weld (Fillet Weld)
Design strength of S275 fillet weld pw = 220 N/mm2