Académique Documents
Professionnel Documents
Culture Documents
Domex 500 MC
Hot rolled, extra high strength,
cold forming steel
Product Applications Chemical composition
Domex cold forming steels are The extra high strength steel C Si Mn P S Al Nb V Ti
thermo-mechanically rolled in grades are used in applications % % % % % % % % %
modern plants where the such as truck chassis, cranes max max max max max min max max max
heating, rolling and cooling and earthmoving machines. In 0,10 0,101) 1,60 0,025 0,010 0,015 0,092 0,202 0,152
processes are carefully these applications, the high
1) If the material is to be hot-dip galvanized, this must be specified in the order.
controlled. strength of the steels is used to 2) Sum of Nb, V and Ti = 0.22% max.
The chemical analysis, save weight and/or to increase
consisting of low levels of the payload.
Mechanical properties
carbon and manganese has As a result of this and the
precise addition of grain refiners good formability of the steels, Yield strength Tensile strength Elongation on failure
< 3 mm > 3 mm
such as niobium, titanium or the total costs can be reduced. ReH N/mm 2
Rm N/mm 2
A80 % A5 %
vanadium. This together with a min min - max min min
clean structure, makes Domex Dimension range 500 550 - 700 14 18
Steels the most competitive
Domex 500 MC is available in
alternative for cold formed and
the range of sizes tabulated
welded products. Bendability
below in as rolled or pickled
Domex 500 MC with
condition with mill edge. Nominal sheet thickness, t
designation D and E meet and
For material with trimmed <3 mm 3 mm <t <6 mm >6 mm
exceed the demands for steel
edges, the width is reduced by
S500 MC in EN-10149-2. Min. recommended 0,6 x t 0,8 x t 1,0 x t
35 mm. bending radius (<90)
Some exceptions may occur.
1) Other test temperatures and impact strengths are available subject to special
agreement.
Welding which gives a weld that can Heat treatment Technical service and
The low contents of carbon, meet the same minimum Stress relief annealing should information
phosphorus and sulphur enable tensile strength requirements be carried out within the Knowledge Service Center will
all conventional welding as the base metal. Some temperature range of 530 - be pleased to assist with
methods to be readily used for examples of different filler 580C. Heat treatment above additional information
Domex 500 MC. No preheating metals that can be used are this range, e.g. normalizing and concerning this product and
is necessary. tabulated below. hot forming, reduces the strength other products from SSAB
There are a large number of and should be avoided. Tunnplt.
filler metals that can be used
for welding of Domex 500 MC,
The particulars in this data sheet are correct at the time of going to print and are intended
to give general guidance for the use of the product. Subject to changes arising from
continual product development. The information and data must not be regarded as
guaranteed values, unless specially confirmed in writing.