Académique Documents
Professionnel Documents
Culture Documents
www.GQIS.co.uk
1.2 Confirm the lift padeye dimension again after repaired (pile No.3568-C06-058)
As per ITP step 15(Production and installation of ancillary) , on 6th September,2016 GQIS inspector found
the lift hole on cheekplate was irregular and the minimum dimension was 60mm, that not in line with the
drawing requirement 74mm, today sub-vendor repaired lifting hole according to the drawing and checked
that dimension was75mm, that satisfactory the drawing requirement.
Picture
Witness UT