Académique Documents
Professionnel Documents
Culture Documents
2003 Altec Lansing Professional y 1000 W. Wilshire Blvd., Suite 362 y Oklahoma City, Oklahoma 73116
Phone: 1.405.848.3108 y Fax: 1.405.848.3217 y Email: proinfo@alteclansing.com
4200A Revision 01
Each amplifier channel shall have a gain of 30dB, an input sensitivity of 1.25VAC RMS at full-rated output and be stable into any load,
including pure capacitors and inductors. The power amplifier shall have four detented attenuators, one for each channel. Each pair of
channels shall have a switched high-pass 50Hz filter, stereo or mono mode, and dual or bridged mode.
The inputs shall be active balanced with an input impedance 10k ohm from a single Euroblock connector. All four amplifier outputs shall be
accessed by terminal strip connection. Each amplifier channel shall have front panel LED indicators for protect, thermal overload, clip, and
signal presence. A temperature sensitive 3-speed cooling fan shall draw air through the front panel and exit the back.
The power amplifier shall be no higher than three rack spaces and must be fully covered with a five year warranty. The dimensions shall be
19 inches (48.3cm) wide by 5.25 inches (13.3cm) high by 16.5 inches (41.9cm) deep. The power amplifier shall weigh 45 pounds (20.4 kg).
The power amplifier shall be the Altec Lansing Professional model 4200A.
Mono Main
Mixer 4200A
1 2 3 4
Bridged
800W @ 8 ohms
DS912-8A
LF115-8A
200W 200W
Mono Choir
Mains Foldback
200W 200W
Subwoofer
As we are continually striving to improve Altec Lansing products, specifications are subject to change without notice.
2003 Altec Lansing Professional y 1000 W. Wilshire Blvd., Suite 362 y Oklahoma City, Oklahoma 73116
Phone: 1.405.848.3108 y Fax: 1.405.848.3217 y Email: proinfo@alteclansing.com
4200A Revision 01