Académique Documents
Professionnel Documents
Culture Documents
A wheel support is shown in the following pages. Draw the exact 3D model of all 5 individual
components (parts in ipt files) shown. Your drawings shall be in correct dimensions and sizes
as shown.
Full marks will be obtained for components that exactly match the drawings supplied.
Create assembly view in dwg or iam file. There are 5 components in a full assembly.
Each one will attract 4 marks if it is properly assembled as Figure A.
Create exploded view in dwg or ipn file. Then, create a drawing in dwg or idw file
exactly as Figure A and B, complete with fully assembly, exploded assembly with balloon
numbering and part list table (Table A).
Make the 2D drawing (in dwg or idw file) for the shaft and bushing complete with
front, top, isometric views, full dimensions and correct scale on A3 paper.
FIGURE D: WHEEL
FIGURE E: SIDE BRACKET
FIGURE F: SHAFT
FIGURE G: BUSHING
END OF QUESTIONS