Académique Documents
Professionnel Documents
Culture Documents
Waleed M Naeem
Saturday, February 4, 2017 4:08 PM Click Here to Join our Whatsapp Route Group
Click here to for CCNP Route Complete Folder
Q1. Which two OSPF network types can operate without a DR/BDR relationship? ?(choose two)
a) Non broadcast
b) Multicast
c) Broadcast
d) Point to point
e) Point to multipoint
Ans: ( Point to point)
Ans: ( point-to-multipoint )
loopback and point to multipoint non-broadcast network types also do not contain DR/BDR
Point to point, point to multipoint the broadcast and non-broadcast is the only 2 network types that require a DR/BDR.
Q2. ipv6 access list and need to apply it to block traffic INBOUND telnet and interface ( choose two )
Ans: there are 5 choices 2 inbound 3 outbound so we have to choose 2 inbound choices only
Explanation:
q about restricting ipv6 access to ssh. Had to pick 2 answers. One that is applied to the fa0/0 and one that is applied to vty lines. Its basically IN or OUT.
Q3. Refer to exhibit. What is indicated by the show ip cef command for an address?
Q4. Which command configures a PPPoE client and specifies dial-on-demand routing functionality?
A. pppoe-client dial-pool-number
B. PPPoE enable
C. interface dialer 1
D. encapsulation PPP
Ans: PPPOE-Client dial-pool-number
Q5. Eigrp is implemented in a frame relay network but there is no adjacency. Which options cause the adjacency to come up?
(choose 2)
Ans: disable split horizon
Ans: neighbor command to configure it for a point to multipoint on the WAN interface
Explanation:
most likely requirements I can think of:
frame relay encapsulation to set
under the physical interface configuration use the no frame-relay inverse-arp command
under the sub-interface configuration use the no ip split-horizon eigrp xyz
Q8. A network engineer recently deploy Easy Virtual Networking in the enterprise network. Which feature improve the service
support??
a. edge interfacing,
b. tunnel feedback,
c. route replication
d. route distinguisher.
Ans: C [should be]
Explanation:
This kind depends on the software release youre running.
Route Replication is supported for static, EIGRP, and OSPF routes. For BGP routes it would probably make use of the export method to copy between VRFs.
From this I would assume the answer to be route replication.
Q9. Which two phases of DMPVN allow the spoke site to create dynamic tunnels to one other (Choose 2)?
Ans: Phase 2 - Hub and Spoke with Spoke-to-Spoke tunnels (mgre everywhere)
Ans: Phase 3
Q11. What is uRPF checking first when the packet enters the interface? Or
When unicast reverse patch forwarding is configured on interface, which action does the interface take list when it received a
packet
a. It check the ingress access list
b. It check the egress access list
c. Route available in FIB or It verifies a reverse patch via the fib to the source
d. It verify that the source has a ??? EEF adjacency
Ans: C
Explanation
When Unicast RPF is enabled on an interface, the router examines all packets received as input on that interface to make sure that the source address and
source interface appear in the routing table and match the interface on which the packet was received. This look backwards ability is available only when
Cisco express forwarding (CEF) is enabled on the router, because the lookup relies on the presence of the Forwarding Information Base (FIB). CEF generates
the FIB as part of its operation.
Q12. Which command instruct a PPPoE client to obtain its IP address from the PPPoe server?
a. Interface dialer
b. ip address negotiated
c. pppoe enable
d. Ip address DHCP
e. Ip address dynamic
Ans: ip address negotiated Collected & Created this Doc by:
Waleed M Naeem
Click Here to Join our Whatsapp Route Group
Click here to for CCNP Route Complete Folder
Ccnp route Exam Page 2
Q13. A network engineer applies the command ip tcp adjust-mss under interface configuration mode. What is the result?
A. The probability of SYN packet truncation is increased.
B. The UDP session is inversely affected.
C. The probability of dropped or segmented TCP packets is decreased.
D. The optimum MTU value for the interface is set.
Ans: C
Explanation:
ip tcp mss-adjust is a brilliant command because in the moment you coordinate the values of layer two frames and layer four segments you greatly reduce
fragmentation that can be a quite big issue considering the environment you are talking about (ISP-MPLS VPN and CE-CE || CE-PE routing
Q14. ALWAYS block the outbound web traffic on Saturdays and Sunday between 1:00 to 23:59 with 4 options out of which
a. Absolute Saturday Sunday 01:00 to 11:59
b. periodic Saturday Sunday 01:00 to 23:59
Ans: b
Explanation:
The question about the time-based acl is also not difficult, you can find out the correct option easily.
The only thing you have to pay attention is about the line with the time, there are two options which are almost identical except for the time notation (12
hours / 24 hours)
Q15. Which two reason for IP SLA tracking failure are likely true (Choose 2)