0 évaluation0% ont trouvé ce document utile (0 vote)
25 vues1 page
This document provides instructions for calibrating the EK-431 SynGas Governor. The steps include stopping the barring gear and starting lube oil pumps, forcing solenoids in the Ammonia PLC-III, opening a startup device in the field, and connecting a Unomat device to outputs on the high pressure and low pressure sides of the barrier for lift calibration.
This document provides instructions for calibrating the EK-431 SynGas Governor. The steps include stopping the barring gear and starting lube oil pumps, forcing solenoids in the Ammonia PLC-III, opening a startup device in the field, and connecting a Unomat device to outputs on the high pressure and low pressure sides of the barrier for lift calibration.
This document provides instructions for calibrating the EK-431 SynGas Governor. The steps include stopping the barring gear and starting lube oil pumps, forcing solenoids in the Ammonia PLC-III, opening a startup device in the field, and connecting a Unomat device to outputs on the high pressure and low pressure sides of the barrier for lift calibration.
2. Force UV431A and UV431B Solenoids in Ammonia PLC-III 3. Startup device to be opened in the field. 4. Connect Unomat to the output of the HP side of the barrier from control room for HP Lift calibration. 5. Connect Unomat to the output of the LP side of the barrier from control room for LP Lift calibration.