Académique Documents
Professionnel Documents
Culture Documents
Net
o adjacency database
o link-state database
o routing table
o SPF tree
o hello
o DBD
o LSR
o LSU
o LSAck
CCNA 5 Page 1
CCNA 2 Chapter 8 v5.0 Exam Answers 2015 (100%) WWW.CCNA-v5.Net
o OSPF will remove that neighbor from the router link-state database.
6. What are the two purposes of an OSPF router ID? (Choose two.)
o 0.0.0.32
o 0.0.0.31
o 255.255.255.224
o 255.255.255.223
9. Which command should be used to check the OSPF process ID, the router ID,
networks the router is advertising, the neighbors the router is receiving
updates from, and the default administrative distance?
o show ip protocols
o show ip ospf neighbor
o show ip ospf
o show ip ospf interface
o metric calculation
o hello mechanism
o OSPF packet types
o authentication
o election process
CCNA 5 Page 2
CCNA 2 Chapter 8 v5.0 Exam Answers 2015 (100%) WWW.CCNA-v5.Net
11. Which three statements describe the similarities between OSPFv2 and
OSPFv3? (Choose three.)
12. What does a Cisco router use automatically to create link-local addresses on
serial interfaces when OSPFv3 is implemented?
o the highest MAC address available on the router, the FE80::/10 prefix, and the EUI-
48 process
o the FE80::/10 prefix and the EUI-48 process
o the MAC address of the serial interface, the FE80::/10 prefix, and the EUI-64
process
o an Ethernet interface MAC address available on the router, the FE80::/10 prefix, and
the EUI-64 process
13. A network administrator enters the command ipv6 router ospf 64 in global
configuration mode. What is the result of this command?
15. Single area OSPFv3 has been enabled on a router via the ipv6 router ospf 20
command. Which command will enable this OSPFv3 process on an interface of
that router?
CCNA 5 Page 3
CCNA 2 Chapter 8 v5.0 Exam Answers 2015 (100%) WWW.CCNA-v5.Net
16. Which command will verify that a router that is running OSPFv3 has formed an
adjacency with other routers in its OSPF area?
o show running-configuration
o show ipv6 ospf neighbor
o show ipv6 route ospf
o show ipv6 interface brief
17. Which command will provide information specific to OSPFv3 routes in the
routing table?
21. Match the information to the command that is used to obtain the information.
(Not all options are used.)
CCNA 5 Page 4
CCNA 2 Chapter 8 v5.0 Exam Answers 2015 (100%) WWW.CCNA-v5.Net
23. Match the description to the term. (Not all options are used.)
24. Open the PT Activity. Perform the tasks in the activity instructions and then
complete the task.
CCNA 5 Page 5
CCNA 2 Chapter 8 v5.0 Exam Answers 2015 (100%) WWW.CCNA-v5.Net
o Finished!
o Completion!
o Success!
o Converged!
CCNA 5 Page 6