Vous êtes sur la page 1sur 2

SPREADER BEAM - ASME BTH - 1

Profile HE300M
W lb 177,031 KG 80,300 Weight of Load
Nd - 2 - 2 Design Factor
Material
Material SA-36
Fy Psi 36,000 MPa 248 Yield Strength
E Psi 29,000,000 MPa 199,948 Modulus of Elasticity
Dimensions
L in 216.5 mm 5,500 Length of Beam
Ixx in4 6,767.9 cm4 281,700 Moment of Inertia
c in 13.1 mm 334 Distance to neutral axis
d in 26.3 mm 668 Depth of Section
b in 6.0 mm 153 Width of compression flange
t in 1.6 mm 40 Thickness of compression flange
Af in2 19.0 mm 12,240 Area of compression flange
2

ry in 18.9 Minor axis radius of gyration


Compact Section
Check that this is a compact section per Table 3-1. Must be a compact section to use this sheet
Check b/t < 0.38*Sqrt(E/Fy)
3.75 < 10.79 Acceptable
Bending Stress
Fb Psi = 1.1 * Fy / Nd =1.1 * 35999.8 / 2 19,800 Allowable Bending Stress (eq 3-6)
M lb-in = W * L / 4 =177031.2*216.5/4 9,581,814 Bending Moment
S Psi = M * c / I = 9581813.7 * 13.1 / 6767.9 18,547 Actual Bending Stress
Check S < Fb
18,546.63 < 19,799.89 Acceptable
Wmax lb =4*Fb*I/(c*L) =4*19799.89*6767.9/(13.1*216.5) 188,994
Gusset Spacing
Lp1 in =0.67*E/(Fy*d/Af) 0.67*28999999.8/(35999.8*26.3/19) 390
Lp2 in =1.76*ry*sqrt(E/Fy) =1.76*18.9*sqrt(28999999.8/35999.8) 944
Lp in =Min(Lp1,Lp2) =Min(389.9,944.1) 390 Max. spacing b/w gussets
Lp in 390 mm 9,903
Check if Lp is greater than Beam Length then it's OK, else change profile
Lp (mm) > L (mm)
9,903 > 5,500 Acceptable

Vous aimerez peut-être aussi