| IB-MMP-200-SA-1011-02, Layout 1 07/11/2011 10:34-Rgees
Full Body Massage Mat
Instruction Manual
AY
MMP-200-SA guaranteeIB-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34 -R@ge2IB-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34-R@ge-3
READ ALL INSTRUCTIONS BEFORE USE.
SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.
IMPORTANT SAFEGUARDS
WHEN USING ELECTRICAL PRODUCTS, ESPECIALLY WHEN
CHILDREN ARE PRESENT, BASIC SAFETY PRECAUTIONS SHOULD
ALWAYS BE FOLLOWED, INCLUDING THE FOLLOWING:
Please Note: For your safely, this product is equipped with a pressure activated switch
to control the heat function. Heat will not operate unless pressure is applied to this switch,
located between the micidle and lower massage zones of the unit (PRODUCT FEATURES)
Once pressure is removed, heat will urn off. Alter applying pressure, please allow 5-10 minutes
for heal to reach maximum temperature,
+ ALWAYS unplug the appliance from the electrical outlet immediately after using and before
cleaning. To disconnect, tum all controls to the ‘OFF’ position, then remove plug fram outlet
+ NEVER leave an appliance unattended when plugged in. Unplug from the mains outlet when
‘notin use and before putting on or taking off parts or attachments.
+ Close supervision is necessary when this appliance is used by, on or near children, invalids or
disabled persons.
+ DO NOT reach for an appliance that has fallen in water or other liquids. Switch off at the
mains and unplug it immediately. Keep dry ~ DO NOT operate in wet or moist conditions.
+ NEVER insert pins or other metallic fasteners into the appliance.
+ Use this appliance for the intended use as described in this booklet. DO NOT use
attachments not recommended by HoMedics.
+ NEVER operate the appliance if it has a damaged cord or plug, if itis not working propery, if
itthas been dropped or damaged, or dropped into water. Return it to the HoMedics Service
Centre for examination and repair
+ Keep cord away from heated surfaces.
+ Excessive use could lead to the product's excessive heating and shorter life. Should this,
occur, discontinue use and allow the unit to coal before operating
+ NEVER drop or insert any object into any opening
+ DO NOT operate where aerosol (spray) products are being used or where oxygen is
being administered,
+ DO NOT operate under a blanket or pillow. Excessive heating can occur and cause fire,
electrocution or injury to persons.
DO NOT carry this appliance by the cord or use cord as a handle.
DO NOT use outdoors.
DO NOT crush, Avoid sharp folds.
This product requires a 230V AC power supply.
DO NOT attempt to repair the appliance. There are no user serviceable parts. For service,
send to a HoMedics Service Centre. All servicing of this appliance must be performed by
authorised HoMedics service personnel only.
+ DO NOT sit or stand on the massage (back) part of the appliance. The unit should only be
Used when attached to a chair with the back in the vertical position
SAFETY CAUTIONS:
PLEASE READ THIS SECTION CAREFULLY BEFORE USING
THE APPLIANCE.
+ Ifyou have any concerns regarding your health, consult a doctor before using
this appliance.
+ Individuals with pacemakers and pregnant women should consult a doctor before using
this appliance.
+ DO NOT use on an infant, invalid or on a sleeping or unconscious person. DO NOT use on
insensitive skin or on a person with poor blood circulationIB-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34-R@ge-4
+ This appliance should NEVER be used by any indiviciual sulfering from any physical ailment
that would limit the user's capacity to operate the controls or who has sensory deficiencies in
the lower halt of their bodly
+ NEVER use directly on swollen or inflamed areas or skin eruptions.
+ Ifyou feel any discomfort whist using this appliance, discontinue use and consult your doctor.
+ This is a non-professional appliance, designed for personal use and intended to provide a
soothing massage to worn muscles. DO NOT use as a substitute for medical attention.
+ DO NOT use before going to bed. The massage has a stimulating effect and can delay sleep.
+ Do not use for longer than the recommended time,
PRODUCT FEATURES
GB
On/Off Targeted
Massage Zones
‘Activate massage
motors to target
specific areas int
body. Customise your
massage program by
choosing any
‘combination of zones
or all four at ones. To
solect a zone, side the
Upper, middle, lower or
legs switch to either
low (L) or high (H). The
corresponding LED.
will ilurinate, To
deselect a zone, simply
slide the switch to the
far left and the LED.
will no longer iluminate
Heat
NOTE: The heat
‘option will only weak
while a massage
feature is selected,
NOTE:
When selecting the heat
feature with massaging
action, there will be a slight
decrease in the strength of
the massage output. This
adjustment is perfectly
normal and should not be
interpreted as a defectIB-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34 -R@ge5
10 Massage Motors
Soothing Heat
Pressure Activated SwitchIB-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34 -R@ge-6
GB
INSTRUCTIONS FOR USE:
Plu
adapter into a 230V AC power supply and plug the receptacle end into the input jack.
located along the side of the mat. For optimum comfort, we recommend that you use your mat
massager on soft surfaces only.
MAINTENANCE
Folding
This massage mat incorporates a unique strapping system that allows
you to fold the unit for storage and transportation. This massage mat
incorporates a folding method similar to an accordion (see Figures 1-4).
Fold the top portion inward so the heat seal pattern is always facing eo
up. Repeat this method. You can also roll up the mat for storage.
Then pull the elastic strap, sewn into the mal, around the unit.
Cleaning (Figure 1)
Unplug the appliance and allow to coo! before cleaning
Clean only with a soft, slightly damp sponge.
+ Never allow water or any other liquids to come into contact with
the appliance
+ Do not immerse in any liquid to clean \ ;
+ Never use abrasive cleaners, brushes, glass / furniture polish \ }
paint thinner etc to clean.
Storage (Figure 2)
Place the appliance in its box or in a sate, clry, cool place. Avoid
contact with sharp edges or pointed objects which might cut or =
puncture the fabric surface. To avoid breakage, DO NOT wrap the
power cord around the appliance, DO NOT hang the unit by the cord. |
Plug (MODEL MMP-200-2GB ONLY)
Ifthe plug on this appliance is damaged, it can be replaced with \
BS 1363 plug, fitted with a 34 BS 1962 fuse. Only use a 3amp fuse
with this appliance. (See Figure 5) (Figure 3)
Care must be taken when changing the plug
if in doubt, contact a qualified electrician.
Plug re-wiring diagram:
1
(Figure 5)
6
(Figure 4)IB-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34 -R@ee7
C € MMP-200-SA_IB-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34-R@ge8
Ea
laste AU slales
Bogergll ay duolS! Anal 5 HLM Glad fay Calg’ TP cde ya pil g SI Syd guce
Aol ple Jpandd
slailly BS a sh day tll yd SIU @ Soll Age od
aad 43) dy) ple Jat Ghat! Jlestul quai dygl lll
iba gg
Ard ye ALS, deg) 0 andy pols bitte ple yilall live Gowaiy
poseyll Gh yquayg SMI fhe ad te way JLEDT g] Lead AlaT
ABS Clie ge gh JS J Shatt NT Leh gpl gl (i
abad Lei ag Lad eis, deb oie, Lali igs!
pall Jg> IAN 8 IL gat ool eh
ga
BBL Jo 2d ALSLY ily sly gS chide (po bush aol
Mili Ales dock dqtiwl bas lysbs (gain
eB! ile gl LS ASU pas ¥
algal GaoLane gf phl all g} dug dl! H jaolure Jostans ¥
AR SU igs) gloat! ope of cle) igs
aus Bis
clgs¥l ES ayby tiles gal ylSo pi atte yi lait east
dey aloes ial BAW Sales yy5 g} 835 05 pI) Bald!
peSMI Le gles My Gil, AN Jg> ab Fay ell GLLy iliyg SII
sack algs
(GB ONLY-T-+-Plug MODEL MMP
sada TGB-1---MMP jl pb go ily gS! CAM yg gh aoe
Abas ge Ai SU 0 gs yotHl ilyg SUI CLL jus JLo ya
dads padi! . UT TABS «ged» agh0 ITIP BS 51h 0 clude
poseyll SI SiN) Basgl! ode go peal F jged
ail alias ab el Jo i dilies gly gS cla) oad oes
yaisre sly gS foley
PU BD ae Ag esIB-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34-Rgge-8
aya olsjaa Vs
Regal ha
BAIL Jal Lib|B-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34_R@ge-4
eh
Sulla Soe Silay Seill pal RL SU TAS ada JLab aie Y +
oll gS gl Gull pal RA Gh gatjell gle yan Sauglpall JULY gle ESL aa oata We +
Lagaall Saya 3 Sli oe Syiley GaLAAl Jo Soe gl geLan DL lal gle BSL Jats Wns +
esha SOI le pggak Ga Lad Lasey Lae Go Gytley ill pal BEM Ga ESL ada Jae Mey +
phan Ge Sie Ileal > jeans
Fanta al pbagl e gOS il si Xaetlall abel GlLill gle tiles JS LaSLall aia danas Wee +
lage jBaly Ve Gys ASL Mandal gal clesil gly oa ol +
Rea Jo las Y Lill Lala yum Jaa NM Lacan yy sige ed ESL +
pol Abe bbe yaks dual) GY gill WI SLA Lo Uglaas Y +
Ae peat gill gl go IST leas Y +
Asal saiall oles
we ltr el i)
Se peal ope
‘ON/OFF
Mat AS J
Beeld
hein 38 dine
inna
amet
wie
Teka a
‘ell del ga TED
ce cone
eat JIB-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34-Rgees
AWS AGS La Landaa! Ud GlsLi, Yi dals (31
May o¥LaaiwY olla Yl oka Baal
Lage olyias
SU 4S SUSI dalsaial sie
Sl dale JlAbY! sgay JLo yg Liold .
tase
Upde Lois Y Lats Ruud! Leda!
ekall p15 ¥ alot (UGG Yaar Y SyLoall pUSiy pall MAN gle aay Lhe Sia Gj dia LaLa thie de +
(tal potent) all lll aba Se lilly Ell SUM Sa apne ty ale
2 10 iS kts ae ical 3p Shang yall Ls Lal gbdiy LL
Lal Jani ya ol yb yg jane pe ole ySll gh Latta Gal +
LayeSl jase Sy ball ne Jd OFF le Sl
le Bel aie ones ae slg gang SS Late Sly ad SLs
TSLULy pee pe Se SLU JURY Spy Shane LSU LALA lal Ls pany Moe Se Uae
BSL Lgl eh ole Lal ald) gal Le gl a ylALll i oady 2
Fy he Gy gh GL lant Yy ESL ind YS JT [yh sg 55a Ge bat aaa
TSU Jala Gh! Loses gh gigi ale JAY «
RS lye ea YUL yl el gl pats Y GaN ha J Chaka Ley GAT SLl ada ucla +
Ue glitts ga Y
Sept
+ Ube Ja YEASL I LAY Jha isle ad Gilani eptll SIS le b EASL edall Jac -
abet Ggleall nSznegan SSI QAI LGA 5S yo ll Lasel aL Ga
Rybpall jules Se slygSll balan +
yaa yam Ja B Layee puss NI YS SLI oda Jackal BS gh
llenial Bolel J ye ia Sab UABYL, UglLeeYl
TSLbassle d
igs she
glgossgidssipsy -
oneaS oN ny ae JAH, olan oy SLI EASE Ja D+
ALM 6S GLI RL taly BSLI be PUL ge yas wb Sully lh oS fa
44 SM sya! Sally
Sibll yg go ESL Jaana Y
sla
I ies LSU Gaus +
soph 230 be ol y4S LS gle BSL ada Jas +
nk SN RSL Jar T pabeaty Gln Gly yi Sipe Led phi an SY) ARASLI pala gla Y «
een Spane pan IS 8S EL Lea She
rrSesengatn
pl apele gnsS pose la) 15 ab alas ell RSL (548) ual LaLa le Gis gi gulag P+
AS ph Go Lipune uses GaldET ed a Lal lacl a
Roladl de ua stalin ts ol oiss
AGSLall Jas! Jub usa GIsLE,Yy Sl pda oba Seld ela pt
RASLall oka JLeatal Ja ovale pated ol pe yee Sle Ge GL aS of +
Sol Joyal ll, Pacemakersiglah la oi jyauds ui al E2M gle +
SeSLall aa JLab asl
1
aIB-MMP-200-SA-1011-02_Layout 1 07/11/2011 10:34 -R@ge42
dual) Jalst tla) gil ali
&>
MMP-200-SA