Académique Documents
Professionnel Documents
Culture Documents
An induction motor is referred with star delta starter for the following reason:
The power is saved because of voltage drops as the starting current is reduced 3-4 times.
The motor is saved because of the star delta circuit comes along with circuit during start of
motor and thus voltage is reduced by three units.
Generator and alternator are two devices, which converts mechanical power into electrical power.
The basic principle followed by both of them is electro-magnetic induction, the only distinction is
their construction. A fixed magnetic field and a rotating conductor is available on the generator
that comes on the armature connected with slip rings and brushes colliding against each other,
hence it transforms the emf induced into the dc current for external load whereas an alternator
has a fixed armature and a rotating magnetic field for higher voltages but for reduced voltage
outcome both rotating armature and stationary magnetic field is used.
a. Maintenance is easy and can change the voltage of AC power for transmission and distribution.
b. Plant cost for AC transmission (circuit breakers, transformers etc) is much lower than the
equivalent DC transmission
c. AC is produced from the power stations so AC is better for usage than DC instead of converting
it.
d. If a big fault occurs in a network, it is simpler to get rid of in an AC system, as the sine wave
current will automatically become zero at some point making the current interruption easier.
4. How can you compare power power engineering with electrical engineering?
Cables, which are used for power transmission, can be classified in three forms:
The emf which is induced developed when the rotating conductors of the armature between the
magnetic poles, in a DC motor, cut the magnetic flux, is a contradiction to the current flowing
through the conductor, when the armature is rotating, is known as back emf. Its value depends
upon the rotational speed of the armature conductors. The initial value of back emf is zero.
Slip can be defined as the difference between the flux speed (Ns) and the rotor speed (N). Speed
of the rotor of an induction motor is always less than its synchronous speed. It is usually indicated
as a percentage of synchronous speed (Ns) and showed by the symbol S.
Storage batteries power are used for various purposes, some of the uses are mentioned below:
For the working of protective devices and for emergency lighting at power generating stations
and substations.
For ignition and automobile lighting, airplanes etc.
As a supply source of power in telephone exchange, labs and broad casting channels.
Many medical centers, banks, non-urban areas where power supplies are not available,
emergency lighting can be the solution.
Join the electrical engineering courses to become an electrical designer int his place.
Stay connected to CRB Tech for more technical optimization and other updates and information.