Académique Documents
Professionnel Documents
Culture Documents
SURFACE COURSES
SURFACE COURSES E
Unit of
Item No. Description/Particulars
Measurement
Bituminous Tack Coat, Emulsified Asphalt
302(2) sq.m.
SS-1
310.1 Description
Each job-mix formula submitted shall propose definite single values for:
After the job-mix is established, all mixture furnished for the project shall
conform thereto within the following ranges of tolerances:
Approval of a new job mix formula may require laboratory testing and
verification.
The mixture shall also have an index of retained strength of not less
than70 when tested by AASHTO T 165. For aggregates having maximum
sizes over 25 mm (1 inch), AASHTO T 165 will be modified to use 150
mm x 150 mm (6 x 6 inches) cylindrical specimens. The 150 mm (6
inches cylinders will be compacted by the procedures outlined in
AASHTO T 167 modified to employ 10 repetitions of a molding load of 9.6
MPa (1400 psi), with no appreciable holding time after each application of
the full load.
310.2.3 Aggregates
Coarse and fine aggregates shall be clean, hard, tough, sound particles
free from decomposed material, vegetable matter and other deleterious
substances.
Heavy Maintenance Works along the Subic-Clark-Tarlac Expressway (SCTEX) Technical Specifications
Part E: Surface Courses Page: E - 1 of 6
SURFACE COURSES E
The coarse and fine aggregates shall meet the following requirements:
e) The flakiness index of the aggregates retained on the 9.5 mm (3/8 in)
sieve when tested in accordance with BS812 shall not exceed 35%.
(The flakiness index of an aggregate if the percentage by weight of
particles in it whose least dimension (thickness) is less than three-
fifths of their mean dimension. The test is not applicable to material
passing a 6.3 mm (1/4 in) sieve.
Heavy Maintenance Works along the Subic-Clark-Tarlac Expressway (SCTEX) Technical Specifications
Part E: Surface Courses Page: E - 1 of 6
SURFACE COURSES E
Fill material shall consist of finely divided rock dust, hydrated lime,
Portland cement or other suitable mineral and shall conform to the
grading shown in Table 310.2.
(%)
To determine the Marshall Specimen Density, for each set of six Marshall
specimens, the highest and lowest densities shall be ignored and the
Marshall Specimen Density shall then be the mean of the densities of the
remaining four specimens
The area to be paid for under this item shall be the number of square
meters (m2) of asphalt pavement placed, compacted and accepted based
on the thickness and density of the cores taken in accordance with
subsection 307.3.10(Acceptance, Sampling and Testing).
Unit of
Item No. Description/Particulars
Measurement
Bituminous Concrete Wearing Course, Hot-
310(1) square meter
Laid (50mm thick)
Heavy Maintenance Works along the Subic-Clark-Tarlac Expressway (SCTEX) Technical Specifications
Part E: Surface Courses Page: E - 1 of 6