Académique Documents
Professionnel Documents
Culture Documents
Introduction
June. 2016
Mobile Wireless Solutions Training Center
Contents
Reduce Operational
Complexity
High Capacity
Transport
Increase Revenue
Concerns for Network Operators
Management Service
Differentiation Fast service
delivery
Intelligent Network design
Automatic Network
Operation New services Engineers skills
Multi-vendor
Consistency
management
Security NMS Performance
Capacity
monitoring
EPC
Latency
Metro
Core
Resiliency
To minimize complexity
E2E
CAPEX QoE Revenue
Enhancement
OPEX
Dynamic, Automatic
Software Defined (SDx)
Networking
Seamless
Boarder
Flexible
less
Mobile Network
Automatic Enriched
New Radio Access Network (RAN) with C-RAN
Backhaul
Fronthaul
RRH
C-RAN
BBU
EPC
Macro
Cell
RRH
Metro
Macro
Small Cell
Cell
Small BBU
Cell BBU
Fronthaul
+SmallCell 60GHz
CWDM
RRH (single fiber)
80GHz CPRI For Fronthaul
80GHz
Fronthaul 60GHz (CPRI)
RRH RRH RRH
CPRI
CPRI Node
80GHz
(CPRI) For Small Cell CPRI CPRI
CPRI 1G
10G
6-42GHz 80GHz
10G
Single fiber
60GHz 1G
CPRI
CPRI
CPRI
1G
10G
10G
Single fiber
1G
CWDM
No Switch /
Ultra low latency
For Fronthaul
80GHz
(CPRI)
RRH RRH
CPRI
Node
For Small Cell CPRI CPRI
CPRI 1G
10G
80GHz
10G
Single fiber
60GHz 1G
CWDM
6-42GHz No Switch /
Ultra low latency
For New Access
Performance issue for new network
Latency
x N nodes
MODEM
MODEM
MODEM
Includes
- Latency
- Delay Variation
Contents
ERPS 2048QAM
RTA XPIC CWDM
1588v2 ETHOAM H-QoS
Redundancy Switch Bypass
Header Comp
SyncE Full synchronization
PWE
iPASO100/200/400/1000 Service Enablement
Main Topics of iPASOLINK VR
3) Service Enablement
Hierarchical QoS (H-QoS) for Multi-service support
Switch Bypass feature for Ultra Low Latency required service
High Capacity Transport
3) Service Enablement
Hierarchical QoS (H-QoS) for Multi-service support
Switch Bypass feature for Ultra Low Latency required service
High Capacity transport with minimum # of channels
(1)
Enable over 1Gbps transfer rate on radio capacity with
single-carrier and single polarization without any
compression technique
l Ultra high modulation (4096QAM) an industry first
l Wider channel bandwidth (112MHz)
28MHz/2048QAM 112MHz/4096QAM
Single carrier /
V V XPIC V or H Single polarization
H H
112MHz
x1.5 x4
max.
10Gbps
10Gbps 10Gbps
*1: compare with 256QAM *2: RTA (Packet Layer) *3: IPv4 compression
All in One (with High Capacity wired & wireless transport)
ODU All-in-One
N-way Radio
High modulation High Speed Interface
Wide band 1G/10G x N (w/CWDM)
MIMO ( >10G )
( >1G )
10G Optical Transport for seamless connectivity
> 1Gbps
10Gbps 10Gbps
10Gbps
> 1Gbps
Intelligent Automatic Operation
3) Service Enablement
Hierarchical QoS (H-QoS) for Multi-service support
Switch Bypass feature for Ultra Low Latency required service
Usability enhancement
GUI setting
or
CLI setting
Non service
interruption F/W
upgrade
E2E management
Various user interface for setting tools
GUI setting
CLI setting
Web-LCT
Export / import file
Bulk setting
ISSU (In Service Software Upgrade)
Primary Secondary
FRAM FRAM
Data Plane
Path1
Path2
Path3
Resource Optimization with Bandwidth Notification
Shaping
rate control Radio bandwidth Link
Radio bandwidth
degradation
information information
Path1
Path2
Reroute
Dynamic Network Optimization
Management
Path Computing
NMS (Self Optimization)
SDN
PCE Network resources
Controller
Dynamically adjust Network paths
Utilization
Availability
Bandwidth degradation by AMR
EPC
Metro
QoS aware Load balance Core
Improve utilization
Transport Multi-Ring Topology Deliver better QoE
Hierarchical & Programmable Rerouting (Rapid
Switching)
Hierarchical Networking with Software Rerouting &
Hardware Rerouting
Minimize switching time (for communication between
controller/NE, for calculation to find out optimum path,
etc) E2E Path Configuration and
Reroute at detecting link
condition change
Ring
Ring
Ring
E2E Path Configuration
and Reroute (BRM)
Hardware Switching
Hardware Switching
(< 50msec)
(< 50msec)
Hardware Switching
Hardware Reroute (< 50msec)
Service Enablement (for business creation)
3) Service Enablement
Hierarchical QoS (H-QoS) for Multi-service support
Switch Bypass feature for Ultra Low Latency required service
Hierarchical QoS (H-QoS) for Multi-service support
Non-MBH service
(VPN, fixed broadband, public Wi-Fi, etc.)
MODEM
MODEM
data
MODEM
Low latency
MODEM
data
ETH
ETH
L2SW
Radio aggregation with dedicated link for low latency
XPIC
(ultra low latency &
mobile service)
MODEM
MODEM
MODEM
For aggregation
Dedicated pipe for XPIC
V
ultra low latency
MODEM
MODEM
H
Compact ODU/
High Power ODU
iPASOLINK
VR
iPASOLINK VR2 iPASOLINK VR4 iPASOLINK VR10
Series
iPASOLINK VR - Next Generation Converged Radio for LTE & beyond -
Enhanced usability
l E2E management (Consolidated FM/PM/CM)
l Various user interface (Web browser, CLI) iPASOLINK VR4
Carrier-grade IP functionalities
l SDN (BRM, OpenFlow) ready, H-QoS, MPLS-TP
l Full range of synchronization (SyncE, 1588v2)
Migration path from current product IAG/IAP ODU iPASOLINK VR10
l IDU: Common chassis (VR10) and common INTFC cards (VR4/VR10)
l ODU: Compatible with IAG/IAP/IHG models*
*restrictions
Sample front view of iPASOLINK VR
Interface Features
l Max. 5 modem l PWE l H-QoS
l 10G x 2 l ERPS l L2 pass-through
l GbE x 8 (SFPx4, RJ45x4) l ETH OAM l SyncE, 1588v2
(2port: 10G or GbE) l CWDM l MPLS-TP, SDN
l PoE x 2
l TDM (E1 x 16, STM-1)
Others
l Compatibility (w/iPASOLINK)
l Universal slot (3 slot)
l Standard protocols (for
management / control)
iPASOLINK VR2 features overview
Compact and low power consumption model for Access and Pre-
aggregation
l 1U single board and all-in-one
l FAN less (Natural cooling)
l 1 or 2 AMR Modems are equipped on main board
l Configurable as 1+0, 1+1, 2+0 and 1+0 XPIC
l 16xE1, 4xGbE/RJ45 and 2xGbE/SFP ports
l ETH OAM
l H-QoS
l SyncE, 1588v2 (TC) / Software upgradable
Flexible Converged Node for Accesses and Aggregation with up to 5way Nodal
l 1U with main card and 3 universal card slots model.
l 0, 1 or 2 AMR Modems are equipped on main board.
l Configurable as 1+0, 2 to 5+0, 2x(1+1), 2x(1+0XPIC) and non MODEM
l 16xE1, 4xGbE/RJ45 and 4xGbE/SFP ports, 2x10GbE, STM-1 (with optional card)
l Various Interface Card type (applicable with iPASOLINK and iPASOLINK VR)
16E1 card, 4xGE card, MSE card (for TDM PWE), STM-1 card
l ETH OAM
l MPLS-TP
l H-QoS
l SyncE, 1588v2 (TC, BC) / Software upgradable
Flexible Converged Node for Aggregation and Metro with up to 12 way nodal
l 3U with main card and 14 universal card slots model.
l Redundant Main card (TDM&Packet: less than 50msec)
l Configurable as 12+0, 6x(1+1), 6x(1+0XPIC), 3x(1+1XPIC) and non MODEM
l Various Interface Card type (applicable with iPASOLINK and iPASOLINK VR)
16E1 card, 4xGE card, MSE card (for TDM PWE), STM-1 card,
l 2x10GbE, CWDM and DWDM (Plan) Metro Network interface
l ETH OAM
l MPLS-TP
l H-QoS
l SyncE, 1588v2 (TC, BC) / Software upgradable
iPASOLINK VR10
Slot No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14
Redundancy Group SWGRP1 SWGRP2 SWGRP3 SWGRP4 SWGRP5 SWGRP6
(1+1)Hot standby No1 No2 No1 No2 No1 No2 No1 No2 No1 No2 No1 No2
(1+1)Twin Path No1 No2 No1 No2 No1 No2 No1 No2 No1 No2 No1 No2
XPIC GRP1 XPIC GRP2 XPIC GRP3 XPIC GRP4 XPIC GRP5 XPIC GRP6
(1+0) XPIC
Master Slave Master Slave Master Slave Master Slave Master Slave Master Slave
(1+1) XPIC GRP1 (1+1) XPIC GRP2 (1+1) XPIC GRP3
(1+1) XPIC
Master1 Master2 Slave1 Slave2 Master1 Master2 Slave1 Slave2 Master1 Master2 Slave1 Slave2
PRTA 2(1+0) Radio GRP1 Radio GRP2 Radio GRP3 Radio GRP 4 Radio GRP5 Radio GRP6
PRTA (3 to 4 links)* Radio SW Group-1 Radio Switch Group-2
PRTA N links (N >4)* Radio SW Group-1
MIMO* SWGP1 SWGP2
1 2 3 4
1 3 4 5 5 6 7 8
2 Main Board 9 MC-MV
10 MC-MV
iPASOLINK VR4 iPASOLINK VR2
11 12 13 14
Slot No. Main Board 3 4 5 Slot No. Main Board Term PS PS
N x (1+0) No1 No2 No3 No4 No5 2 x (1+0) No.1 N0.2
Redundancy Group SWGRP1 SWGRP2 Redundancy Group SWGRP1
(1+1)Hot standby No1 No2 No1 No2 (1+1)Hot standby No.1 N0.2
(1+1)Twin Path No1 No2 No1 No2 (1+1)Twin Path No.1 N0.2
XPIC GRP1 XPIC GRP2 XPIC GRP1
(1+0) XPIC (1+0) XPIC
Master Slave Master Slave Master Slave
PRTA 2(1+0) Radio GRP1 Radio GRP2 PRTA 2(1+0) Radio GRP1
iPASOLINK VR 10
Slot No. 1 2 3 4 5 6 7 8 9 10 11 12 13 14
Modem EA / A
Modem AV*(112MHz/4096 QAM)
GbE-A (2RJ45+2SFP) 3 Ports
GbE-AV (4SFP) 3 ports
GbE-2AV (2RJ45+2SFP) 2GbE
XGbE-MV
STM1-A
16 E1-A
MSE-A**
CWDM-A/B
iPASOLINK VR4 1 2 3 4
Slot No. Main Board 3 4 5 5 6 7 8
Modem In-built modems EA / A EA / A EA / A 9 MC-M
Modem AV* In-built modems AV* AV* AV* 10 MC-M
GbE-A 11 12 13 14
GbE-AV
Term PS PS
GbE-2AV
XGbE-MV
STM1-A
16 E1-A 16E1 Main Board
MSE-A***
* Future Release
** 2X MSE card can be used with SW Key for more than 64E1 PWE. And
*** 1x MSE card only
iPASOLINK VR10 features overview
iPASOLINK Sync Supports
TDM
2G/3G ETH M
S TDM Boundary
1588v2 1588v2 BSC/
1588v2 Clock
RNC
1588v2 (transparent) (transparent)
ETH M MME
eNB ETH
S
CLK-IN: 1588v2 CLK-IN: - CLK-IN: - CLK-IN: - CLK-IN: 1588v2(OC)
TDM
2G/3G 1588v2 ETH 1588v2
M
S TDM Boundary
(transparent) (transparent) BSC/
1588v2 Clock
RNC
1588v2 Synch-E Synch-E
M Master ETH M MME
Slave eNB Synch-E
S S
CLK-IN: 1588v2 CLK-IN: - CLK-IN: - CLK-IN: - CLK-IN: 1588v2(OC)
iPASOLINK VR10
iPASOLINK VR2
Default
iPASOLINK VR4
Contributions;
l Converged Network with High capacity MW & Optical transport
l Operations automation leveraging NECs market leading
solutions:
SDN, NFV
Operation & Orchestration
[NEC Confidential]
iPASOLINK VR Series
(Appendix-1)
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
Contents
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
Ultra multi-level modulation (4096QAM)
implementation
NEC is the pioneer in ultra high modulation
l Has achieved 1Gbps transmission with 2048QAM in
commercial use
l Developing 4096QAM to give more flexibility to support large
capacity
More than 1Gbps full transmission radio w/o compression
Reduce Bit Cost: 83 % OFF (QPSK => 4096QAM) more
1Gbps
2048QAM
4096QAM
1024QAM 1Gbps
25% up
512QAM Commercial use
11% up
256QAM
Wider channel BW 112MHz
56MHz 112MHz
1000M
500Mbps x2 bps
(56MHz/2048QAM) (112MHz/2048QAM)
4 x 4 LOS-MIMO
1
sig2
4x4 MIMO
sig3
sig4
Quadruple capacity
* Theoretical value
on a single spectrum
Radio Traffic Aggregation channel number extension
V V
1Gbps H H 1Gbps
28MHz 28MHz
Bandwidth maximizer for more L1 throughput
Bandwidth Bandwidth
Maximizer Maximizer
Compressed
idx
FCS Payload Header IFG Payload FCS Payload Header IFG
L2 Compression
preserved
IFG/PRE Suppression l In addition, Lempel-Ziv based
data compression will be
available, if it fits on network
SLA.
10G Wireless Transport (sample calculation)
56MHz/4096QAM (530Mbps/ch)
V V V V XPIC
H H H H
56MHz 56MHz56MHz56MHz
10Gbps
IPv4 IPv4
comp. comp.
10G 10G
Contents
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
10G Optical Transport use cases
l Feasible to use in more than 1Gbps metro network and to provide seamless
connectivity with 10 optical transport network by supporting 10G interface
10G 10G
>1Gbps
Core
Metro Network
10G 10G
l Provide more efficiency and resiliency transport for high capacity aggregation
traffic by 10G link aggregation
>1Gbps >1Gbps
Metro
10G
>1Gbps >1Gbps
Contents
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
Service Enablement
Enriched features targeting for E2E service enablement with enhanced
networking
l QoS management per VLAN with Hierarchical QoS
l Multi service support
l High speed transport with Intelligent management/control
Multi-service support with heterogeneous transport (Fronthaul through Backhaul
until Metro)
l Combination with all-outdoor radio solution
l Switch bypass function for ultra low latency for Fronthaul (C-RAN)
VPN
H-QoS
(C-RAN) Data
High speed INF
RRH
Low latency Center
RRH BBU Core
etc.
HetNet Internet
(Small Cell)
VPN
Hierarchical QoS
Hierarchical QoS helps to ensure QoS control for each services in the
network providing multi-service
Supporting hierarchical Ingress policing and Egress shaping /
scheduling
l Per Port
l Per Port + QoS Class
l Per Port + QoS Class + VLAN
When using same priority between each operators, Class queue will be separated between each
class queue will be shared with each operators. operators since it has class queues per VLAN even if
impossible to manage QoS control per each using same priority between each operators.
operators
Aggregation Option (L1/L2) and Performance (Latency)
X>Y>Z
L2 aggregation V/H aggregation (XPIC) lambda aggregation (CWDM)
Latency = (2 x Y) + X
Y Y > Latency = 2 x Y
Y Y
XPIC
> Latency = Y + Z
Y Z
MODEM
MODEM
MODEM
V
PHY
X CWDM
MODEM
CWDM
MODEM
Single fiber
MODEM
MODEM
MODEM
PHY
MODEM
Switch Switch
Includes Bypass Bypass
- Latency IDU IDU IDU
- Delay Variation
XPIC
CWDM
L2 aggregation
(statistical aggregation) V/H aggregation Lambda aggregation
(XPIC) (xWDM)
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
Network performance analysis
Usage report
Network performance analysis image
Path Configuration
l Calculates according to the path parameter and creates optimum
path, then sets configuration of each NE by setting two end points.
Re-routing and network load-balancing
l Detects the modulation change and then finds out optimum
alternative path, and reroutes before data rate degradation of
affected VLAN.
BRM Controller
BRM Controller BRM Controller
Re-routing
Automatically
path creation Link
degradation
End-to-end
Provisioning
Service Enablement
Hierarchical QoS
Switch Bypass
Usability Enhancement
iPASOLINK VR specifications
Image for Backhaul and Fronthaul Convergence
For Fronthaul
80GHz
(CPRI)
RRH RRH
CPRI IDU
CPRI CPRI
CPRI 1G 80GHz
80GHz 10G (CPRI)
10G
Single fiber
60GHz 1G
CWDM RRH
60GHz/80GHz No Switch /
Ultra low latency
For Small Cell CPRI CPRI
Physical connection
CWDM 2 x CPRI
1G
1G
10G
10G
1G 1G 1G
60GHz/80GHz
60GHz
80GHz
Supported Features
TDM
Transport ETH / Layer-2 Switch
Network
Architecture TDM PWE
MPLS-TP
H-QoS
QoS Prioritization
Bandwidth Management (Policy)
SyncE
Synchronization
1588v2 TC TC,BC TC,BC
16xE1 card
Interfaces chSTM-1 with APS option card
4xGbE card (RJ-45x2 + SFPx2)
Optional - MSE card (64xE1 TDM PWE)
CWDM Filter card
10GbE card
MODEM-EA
4xGbE card
16xE1 card New MODEM card
STM-1 card 10G card
MSE card (for PWE) New 4xGbE(SFP) card
CWDMFA/B card New 2xGbE card (w/ PoE)
NEW
Universal Universal
Card Card
400/400A VR4
1000 VR10
Appendix
MODEM-EA
MODEM-EA
Equivalent to 2048QAM
Equivalent to 2048QAM
MODEM-A
MODEM-A Equivalent to 512QAM
Equivalent to 512QAM
IAP IAP
MODEM Air Compatibility
VR2 OK OK OK OK OK OK
VR4/VR10 MODEM-EA OK OK OK OK OK OK
100A/200A OK OK OK OK OK OK
400A MODEM-EA OK OK OK OK OK OK
400/1000 MODEM-EA OK OK OK OK OK OK
iX OK OK OK OK OK OK
VR10 MODEM-A OK OK OK OK
400A MODEM-A OK OK OK OK
400/1000 MODEM-A OK OK OK OK
100E/100/200 OK OK OK OK
Note: Air compatibility does NOT support between MODEM-A type and MODEM-EA type