Académique Documents
Professionnel Documents
Culture Documents
a. 25 meters
b. 50 meters
c. 75 meters
d. 100 meters
e. 328 meters
2. Which type of cable should be used to swap out a bad run in a 1000BaseT network?
a. RG-56 or series 6
b. Category 5 UTP
c. Category 5e UTP
d. Multimode fiber
3. ** CORRECTED **
a. 2
b. 3
c. 4
d. 5
e. 8
Show Explanation
(Choose three.)
a. MDF
b. BDF
c. FDF
d. IDF
e. MPoE
Show Explanation
a. Category 6b
b. Single-mode fiber
c. Multimode fiber
d. Category 6
Show Explanation
True False
a. F
b. ST
c. SC
d. MT-RJ
a. Coax
b. Fiber optic
c. UTP
d. Category 5
a. RJ-45
b. ST
c. SC
d. BNC
e. F-Connector
f. RJ-14
a. Category 2
b. Category 5e
c. Category 6a
d. Category 8
Show Explanation
12. ** CORRECTED **
a. 1
b. 2
c. 4
d. 8
13. You are wiring a new home network for a subscriber. Due to space limitations at the location, you need to run
several cables close to each other. After the setup, you find that the signals from each cable are overlapping.
Which term describes what is happening?
a. Attenuation
b. Crosstalk
c. Near crosstalk
d. EMI
Show Explanation
14. ** CORRECTED **
(Choose 3)
a. Ferrule Connector
b. Subscriber Tip
e. Straight Tip
Show Explanation
15. As a home network installer, you need to verify proper wiring of a RJ-45 T568B termination on category 5e. What
color wire is associated with pin 4 of a T568B termination?
a. white/orange
b. blue solid
c. green solid
d. white/brown
Show Explanation
16. You have been called in to replace a faulty ST connector in a small business. Which of the following media types
are you working with?
a. RG-56
b. Single-mode fiber
c. SCSI
d. RJ-45 crossover
17. ** CORRECTED **
Which RJ-45 connector pin out configuration would be used to connect a host computer into a switch?
a. UTP
b. Straight-through
c. Crossover
d. Rolled
18. ** CORRECTED **
Which of the following connector types would a home network technician use to connect a serial cable?
a. RJ-11
b. BNC
c. AUI
d. DB-9
a. RF
b. F-81
c. RJ-45
d. BNC
20. ** CORRECTED **
Which of the following describes the loss of signal strength as a signal travels through a particular medium?
a. Attenuation
b. Crosstalk
c. EMI
d. Chatter
21. ** CORRECTED **
Which Broadband over Power Lines standard exists for high-speed communication devices?
a. IEEE 802.11
b. IEEE 802.3
c. IEEE 1901
d. IEEE 1394
Show Explanation
22. ** CORRECTED **
a. Category 6a UTP
b. Single-mode fiber
c. Coax
d. Multimode fiber
23. Category 6a (augmented) was designed to support greater distance, 100 meters or 328 feet, by improved crosstalk
characteristics.
True False
24. After 100 meters (328 feet), CAT6 cabling is known to experience which of the following symptoms?
a. signal bleed
b. signal loss
c. data collision
d. crosstalk
25. ** CORRECTED **
26. Which coax cable is used in our cable industry for wiring the subscriber premises?
a. RG-58 A/U
b. Series 6
c. F-type 81
d. RG-59/U
Show Explanation
27. ** CORRECTED **
Show Explanation
28. When designing a network, you have been asked to select a cable that offers the
most resistance to crosstalk. Which of the following are you likely to choose?
a. Multimode fiber-optic
c. UTP
d. Shielded mesh
29. ** CORRECTED **
Cable operators will continue to search for increased bandwidth. Cable operators SONET over single mode fiber
supports OC-768. How much bandwidth does OC-768 support?
a. 155Mbps
b. 2.5Gbps
c. 10Gbps
d. 40Gbps
e. 100Gbps
Show Explanation
30. Serial cables offer a distance of 200 feet with a speed of 200Kbps.
True False
Show Explanation
31. ** CORRECTED **