(Identical with ASTM Specification A 516/A 516M-90.
1. Scope 2. Referenced Documents
1.1 This specification covers carbon steel plates 2.1 ASTM Standards: intended primarily for service in welded pressure vessels A 20lA 20M Specification for General Requirements for where improved notch toughness is important. Steel Plates for Pressure Vessels A 435lA 435M Specification for Straight-Beam Ultra- 1.2 Plates under this specification are available in four sonic Examination of Steel Plates grades having different strength levels as follows: A 577lA 577M Specification for Ultrasonic Angle-Beam Tensile Strength, Examination of Steel Plates Grade U.S. [SI] ksi [ m a ] A 578lA 578M Specification for Straight-Beam Ultra- 55 [380] 55-75 [380-5151 sonic Examination of Plain and Clad Steel Plates for 60 [415] 60-80 [415-5501 Special Applications 65 [450] 65-85 [450-5851 70 [485] 70-90 [485-620] 3. General Requirements and Ordering 1.3 The maximum thickness of plates is limited only formation by the capacity of the composition to meet the specified 3.1 Material supplied to this material specification mechanical property requirements; however, current shall conform to Specification A 2011: 20M. These practice normally limits the maximum thickness of plates requirements outline the testing and retesting methods furnished under this specification as follows: and procedures, permissible variations in dimensions, and mass, quality and repair of defects, marking, loading, etc. Maximum Thickness, Grade U.S. [SI] in. [mm] 3.2 Specification A 20lA 20M also establishes the 55 [380] 12 [305] rules for the ordering information that should be complied 60 [415] 8 [205] with when purchasing material to this specification. 65 [450] 8 [205] 70 [485] 8 [205] 3.3 In addition the basic requirements of this specifi- cation, certain supplementary requirements are available when additional control, testing, or examination is 1.4 The values stated in either inch-pound units or required to meet end use requirements. These include: SI units are to be regarded separately as standard. Within the text, the SI units are shown in brackets. The values 3.3.1 Vacuum treatment, stated in each system are not exact equivalents; therefore, 3.3.2 Additional or special tension testing, each system must be used independently of the other. Combining values from the two systems may result in 3.3.3 Impact testing, and nonconformance with the specification. 3.3.4 Nondestructive examination.