Académique Documents
Professionnel Documents
Culture Documents
Note: Encircle the letter of only one alternative which you think is most appropriate.
a. The three bend tests are acceptable and the fourth one
is not acceptable
b. The test result overall is acceptable
c. The test result is not acceptable due to the linear indication
d. The bend test result is indeterminable, carry out retest.
a. GTAW
b. SMAW
c. GMAW
d. SAW
1
API 653
a. F no. 4
b. F No. 3
c. F No. 2
d. F No. 1
7. The welder who welded the test plate for PQR 101 is qualified to
weld in what position?
a. Flat
b. Flat and horizontal
c. Flat and vertical
d. Flat, vertical and horizontal
8. The bend test specimen used are side bend. They are:
a. Not accepted since 2 face bend and 2 root bend must be used
b. Accepted since as alternative to (a) 4 side bend may be used
c. Accepted since only 2 bend tests are required where as 4 bend
tests are performed
d. Not accepted since all 3 types of bend tests (face, root, side)
are required.
9. As far as thickness ranges for Base Metal (B.M.) and weld metal
(W.M.) as shown on WPS are concerned, your decision about the
qualified range is:
2
API 653
11. Based on the specimen areas provided in PQR, are the ultimate
stress calculations correct (as rounded up to psi) for specimen T1
and T2:
12. Which condition below best describes the result of tensile tests
reported on the PQR?