Académique Documents
Professionnel Documents
Culture Documents
Pneumatic gauge
Short description
l
Economic measuring system acc. to the bubble
principle
l
Highly precise and robust by drift free sensing
and automatic 0-point adjustment
l
Compensation of temperature influence
l
Processor supported sensor linearisation
l
Low energy consumption thanks PS-Light-2C
to intelligent pump control
l
Modular system
l
Optionally with RS485, SDI-12, 0/4..20mA,
0..1V, 0..5V, BCD-, Binary- or Gray-Code output
Application at
a river
Measuring site
Installation together
PS-Light-2C Station with Powerbox ZV
We are certified
Q
Building site Easy installation ISO 9001:2008
Certificate No. 01150509
The SEBA-pneumatic gauge type PS-Light-2C allows low energy consumption, and enables
serves as a robust, economic and reliable operation with batteries or solar panels, without
measuring system for monitoring water levels in the need for mains power supply.
surface waters. The measuring principle is the The sensor system works on base of an automatic
proportioning or bubbler system, based upon the 0-Point adjustment and therefore compensates
other well-known SEBA instruments in the PS- temperature and other drift effects entirely
series. before every measurement process.
An integrated, highly efficient mini compressor,
bubbles air through the pressure tube into the The basic version of the PS-Light-2C is a sensor
water at adjustable intervals. The resultant with optional output. However it can be equipped
pressure in the tube corresponds exactly to the with LC-display, datalogger or remote data
hydrostatic pressure above the mouthpiece. This transfer via GSM/GPRS. The basic version is
tube pressure is then measured by a very delivered in a robust protective housing (IP65)
accurate pressure sensor in the PS-Light-2C . suitable for wall or desk mounting. SEBA PS-
Light-2C can be connected to existing pressure
The intermittent operation of the PS-Light-2C tubes at any time.
key for
manual purging
supply
enable
RS232 (optional USB)
air inlet Configuration & readout interface
signal output zero set for connection to HDA, Laptop etc.
0...5V, opt. bubbler
0/4...20mA, tube
Gray, BCD, Binary
pneumatic gauge
PS-Light-2C
pressure
tube
mouthpiece
Data flow
modem
online
GSM/GPRS, phone, wireless
FTP-Push, SMS data transmission
Line /GSM/GPRS
online
modem
PS-Light-2C Notebook
PS-Light-2C-Sensor-LCD
PC
PS-Light-2C-Sensor
PS-Light-2C-GSM
PS-Light-2C-LCD
PS-Light-2C
SEBAConfig
SEBA data logger
DEMASdB
WinOperate
integrated offline DEMASdB
DEMASvis
Wiski/Soda
DEMASole
0..1V, 0..5V, 0/4..20mA
0..1V, 0..5V, 0/4..20mA
PC - Desktop Computer
BCD, Gray, Binary
BCD, Gray, Binary
SEBA-HDA-Tablet
- data logger of other
manufacturer
Rs232
(Rs485) - SPS
SDI-12 - Data Transmission
Systems online
PS-Light-2C
SEBA - Data Logger (for types PS-Light-2C Logger and PS-Light-2C Logger LCD):
Microprocessor: 32Bit
Measurement storage: Ring storage, 16-bit resolution, storage of check values.
Clock-, average- and eventmode are freely programmable
max. 32 channels (water level, battery voltage, external channels RS485)
Flash-Memory: 4 MB for approx. 280.000 measuring values
Power Supply: 10...30 VDC
Measuring Interval: freely programmable from 1 minute via software SEBAConfig
Option: LC-Display for instant indication of water level
Power Supply
- PS-Light-2C powersupply, 220VAC/12VDC
- PS-Light-2C powersupply, buffered with 100Ah
- PS-Light-2C powersupply, buffered with 7,2Ah - Battery 100Ah
- Solar power supply is possible
Software
DEMASvis
Readout & Configuration : SEBAConfig and DEMASole
Management /Evaluation Software: DEMASdB / DEMASvis
SEBAconfig
The right is reserved to change or amend the foregoing technical specification without prior notice.