Académique Documents
Professionnel Documents
Culture Documents
onlineminingexam
MENU
WRITTEN BY MININGEXAM
1) Exhaust / Retarder braking system in a truck;
1. a) Is primarily to protect the service break from excess heat and save wear
1. b) Can stall the engine if the speci ed engine speed is not maintained
1. d) All above
4) No drill shall be used for boring a shot hole unless it allows a clearance of atleast over
the diameter of the cartridge of explosive which it is intended to use.
1 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
6) Sound level of Audio Visual Alarm (AVA) should be at least higher than theambient
noise level.
9) As per Reg.177 of MMR 1961 Every Fence erected on the surface shall once at least inevery week
be
examined by .
11) What are the UNSAFE WORKING CONDITIONS at Mines? Choose from the following.
1. a) 25 b) 20 c) 15 d) 30
13) Voltage shall not exceed Volts for hand held portable apparatus used in theMines as per
CEA Regulations. 2010.
2 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
15) Which of the following are the main factors responsible for Blast induced ground vibrations?
19) First-Aid Room shall have oor space not less than .
20) Notice of accident causing death or serious bodily injury in connection with miningoperations, in
Form IV
hours.
1. a) 24 b) 48 c) 72 d) 12
22) Who will set permanent or temporary speed limits, for any area of the Mine or anyvehicle or
class of vehicle?
23) If any employee contracts a noti ed occupational disease, the Mine Management shallsend
notice to Regional Inspector in
3 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
1. a) 60 b) 200 c) 45 d) 500
27) Pointing out of contraventions by Chief Inspector or Regional Inspector of Mines shall be
entered in
28) Operators Seat in the Vehicle / HEMMs should be designed tohave adequate
comforts while driving continuously.
30) In Opencast Mining, the width which is extracted from the working bench is termed as
31) Minimum length of safety fuse at the ring end shall not be less than
32) Who are the persons not holding position of supervision or Management, choose fromfollowing,
33) As per Regulation- 36 of MMR 1961, in opencast mines worked by HEMM, MechanicalEngineer
shall be appointed, where aggregate H.P. of all machineries exceeds
1. a) 1st Apr to 31st Mar b) 1st Jan to 31st Dec c) 1st Jan to 30th Sep d) 1st Oct to 31st Dec
4 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
1. a) Improves mine e ciency, reduces down time and cuts maintenance costs
1. d) All above
Mines.
38) Notice of Medical examination under 29D of Mines Rules 1955 shall be given
in
39) Every Women employed in a mine above ground shall be allowed an interval of not less
than hours between the termination of employment on any one day thecommencement of the
next period of employment.
1. a) 11 b) 12 c) 24 d) 16
40) For employees engaged in Driving / HEMM operation jobs, eye refraction test should
beconducted one in Years.
1. a) 2 b) 1 c) 3 d)5
41) The explosives shall be transported to the site of blasting not more than
commencement of charging of the holes.
before the
42) Which of the following are the examples of an inadequately maintained haul road?
1. d) All above
43) The energy shall not be transmi ed in to a Mine at a voltage exceeding andshall not be
used therein at a voltage exceeding .
5 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
44) Pit slope is the angle made by the imaginary line joining the
1. b) Top most toe of the bench to the bo om most toe of the benc
45) Maximum Exposure Limit of dust prescribed for 8 hrs time weighted average in Mine
workingenvironment.
48) A successful accident investigation must answer three questions: What are they?
1. c) Why did they do? 2. Why they couldnt avoid it 3. What went wrong?
49) Which of the following features should be shown in water danger plan?
6 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
1. e) All above
51) If the mine wherein 1600 persons are ordinarily employed, the number of WorkmenInspector
required as per as per Rule 29 Q of Mines Rules 1955.
1. a) 2 b) 3 c) 4 d) 5
53) Pit slope is the angle made by the imaginary line joining the
1. f) Top most toe of the bench to the bo om most toe of the benc
54) As per 106 of MMR 1961, No tree, loose stone or debris shall remain within a distance of
from the edge or side of excavation.
1. a) 5 m b) 4m c) 3 m d) 2 m
55) If the percentage of free respirable silica present is 10% in the atmosphere , what is
thepermissible limit of free silica in milligrams per cubic meter of air sampled.
1. a) 1.5 b) 3 c) 10 d) 5
56) As per 173 of MMR 1961, the hydraulic test for the air receiver to be done at a pressure ofat least
- times the maximum permissible working pressure.
1. Medical certi cates should be retained for 5 years from the date of medical examination
1. Medical certi cates should be retained as long as the person employed in mine.
1. Medical certi cates should be maintained as long as the person employed and 10 years thereafter.
1. Medical certi cates should be maintained as long as the person employed and 5 years thereafter.
58) The annual returns submi ed to the DGMS as per First Schedule of which form?
7 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
61) Miner died due to heart- a ack during his duty hours without any injury . which of thefollowing
statements is
1. If post mortem report fails to submit to DGMS it is considered as accident in the Mine.
2. In case of Semi Mechanised area of maximum of 4 Mate districts with 2 KM at area as radius.
64) The bench height is 6m, depth of the hole is 6.6 m (includes sub grade drilling), spacing is 4 m,
burden is 5 m, the density of the rock is 2, and explosive used is 24kg. Find thepowder factor.
8 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
1. a) 12 b) 10 c) 24 d) 11
65) As per Reg.177 of MMR 1961 Every Fence erected on the surface shall once at least inevery week
be examined by .
66) Which of the following is in the part of ISO (Internal Safety Organisation)
i. Managing Director
ii. Director Technical
iii. Safety o cer
iv. None of the above
a) 1 & b) 3 c) 1, 2 d) 4
2 &3
67) Which of the following is true regarding the workers participation in safety management?
1. b) Commi ee
1. c) Tripartite commi ee
68) The number of man days in the year 2014 is 26500, rest days are 54, and non working daysdue to
sick are
46. Find the persons ordinarily employed in the Mine. Consider the yearmeans 365 days.
70) The handling gures of the Mine for the year 2014-15 are as below.
The OB hanlding = 5,00,000 Tonnes , ore production = 2,00,000 Tonnes and densities of OB and Ore
are 2.5 and 3respectively . Find the stripping ratio for the year 2014-15.
2. a) 1: 2.5 b) 2.5 : 1 c) 1: 1 d) 5 : 2
71) Which of the following are not the safety features of Belt conveyors?
9 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
72) As per DGMS Circular No 36/1972, nd the minimum width of the bench with the
followingdata?
The Height of the bench is 7 m , The boom reach of the machine is 6 m , the tipper plying on the
bench , where tipperwidth is 2.5 m and the widest machine Hitachi Ex800 working on the bench ,
where the EX 800 width is 5.5 m.
7. a) 7.5 m b) 6 m c) 7 m d) 5.5 m
74) If the depth of pit reaches meters the scienti c study on slope stability will bedone by
scienti c agency.
1. a) 60 m b) 75 m c) 50 m d) 100 m
========================================================================
========================================================================
No. No.
1 d 41 a
2 a 42 d
3 e 43 d
4 d 44 a
5 b 45 b
6 a 46 e
7 b 47 c
8 d 48 a
10 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
9 d 49 e
10 b 50 b
11 f 51 b
12 a 52 d
13 b 53 a
14 d 54 c
15 f 55 a
16 a 56 d
17 d 57 c
18 b 58 c
19 b 59 d
20 a 60 d
21 c 61 c
22 a 62 b
23 d 63 a
24 d 64 b
25 c 65 d
26 c 66 a
27 b 67 d
28 d 68 c
29 b 69 c
30 b 70 c
31 a 71 d
32 f 72 a
33 a 73 a
34 b 74 a
35 c 75 d
36 d
37 a
38 a
39 a
40 b
11 of 12 8/1/17, 11:50 AM
Mine Legislation | MCQ Multiple Choice Questions | Answer | DGMS... https://onlineminingexam.wordpress.com/2015/10/26/mine-legislatio...
12 of 12 8/1/17, 11:50 AM