SECTIONS
FRONT DRIVE SHAFT
ENERAL DESCRIPTION = 3—193
‘DISASSEMBLY AND ASSEMBLY ~*~ u . 3—194
GENERAL DESCRIPTION
velocity balliointis used on the wheel side of front drive shatt to transmit smooth traction force in case of
ange. On the differential side, constant velocity tipotjoin! type or double offset joint type of which sliding
fance is smallis adapted. -
Differential sida
CI
‘Tripot joint type
Ditterential side
Double offset joint ype|OON)DISASSEMBLY AND ASSEMBLY
Drive shaft
Breton bot ea
roti jean
plies
( o
Wom spire Daragad sn
FIG. 3—2 DISASSEMBLING DRIVE SHAFT
Disassembly 2. After removing grease and circlip, remove spi
ease from shaft. q
CAUTION
+ Disassembling wheel side joint is notallowed,
In case of replacement, replace boot afte:
disassembling differential side jont.
+ When replacing shaft, make sure that boot
shall not be damaged.
1. Remove differential side boot band and joint
housing (In case of DOJ, remove snap ring)
4. Spider
2. Boaring
3. Circlip
FIG.3—4 REMOVING CIRCLIP
(TRIPOT JOINT TYPE)
(In case of DOJ type, remove six balls)
1, doint Reusing
FIG. 3— 3 DISASSEMBLING JOINT HOUSINGgure to check abnormality before disassembling
check visually atter dsassembling to replaceand
smble parts correcty.
Geaning joint housing disassembled, dry it
pletely usingair blower and clean bootwith ciot.
joint grease on wheel side joint or inner side of
stall ferential sida boot on shaft, apply grease on
int and inner side of boot.
int assembly.
ere