Académique Documents
Professionnel Documents
Culture Documents
This example walks through the design of a concrete T beam with the depth of
the compression block less than the depth of the flange
Given:
fc = 4,000 psi
fy = 60 ksi
Required:
Assumptions:
Next, well calculate d, the depth from the extreme compression fiber to the center of reinforcement in the tensile zone.
Next, we want to use equilibrium to solve for a, the depth of the Whitney stress block
Now that we know the depth of the stress block, we can calculate c, the depth to the
Solve for a: neutral axis.
With c, we can calculate the strain in the extreme tensile steel using similar triangles.
With this strain calculated, we can check our assumption that the steel yields, and
determine if the section is tension controlled.
Per ACI section 10.3.4 a beam is considered tension controlled if the strain in the extreme tension steel is greater than 0.005.
The calculated steel strain in our section is 0.054 which is greater than 0.005 therefore this beam section is tension controlled.
= 0.90
Determine the strain at which the steel yields and check our assumption that the steel in fact yielded:
E = fy/y
E = Youngs modulus which is generally accepted to be 29,000 ksi for steel
fy = steel yield stress
y = yield strain
y = 60ksi / 29,000 ksi = 0.00207
0.054 is greater than 0.00207 therefore our assumption is correct and the steel yields prior to failure
Next, lets determine if the beam section satisfies the minimum steel requirements of ACI:
Per ACI section 10.5.1, the minimum steel required for flexural members is as follows:
Using Moment Equilibrium, Lets Calculate the Moment Capacity of the Section
Calculate the moment about the center of the compressive force to determine the
nominal moment capacity: