Académique Documents
Professionnel Documents
Culture Documents
End Plates
Y-Axis Rail Assembly (PS20026)
Overview
Note: Although the assembly photo shows both end plates attached, only attach one to each Y-axis rail
at this time.
Requirements
Parts
1. End Plate (12ga) 26028-01 x 2 pcs.
2. M5 x 12mm, BHCS 25286-02 x 4 pcs.
http://docs.shapeoko.com/yaxis.html Page 1 of 2
Shapeoko 2 - Y-Axis Assembly 3/3/14 2:41 PM
Slide two Belt Clip Anchor Assemblies (#4) into the top slot of the MakerSlide (#5).
Attach one end plate (#1) to each piece of MakerSlide using the 12mm M5 bolts (#2) and M5 washers
(#3).
Do not attach the second end plate, that will be done in the next step.
http://docs.shapeoko.com/yaxis.html Page 2 of 2