Académique Documents
Professionnel Documents
Culture Documents
Home Forums Engineering Computer Programs Engineering Programs DASSAULT: CATIA products Forum
I am bringing in a 2D profile from an IGS file, the profile has 3700 elements (lines and curves) then it has a totally new set of
lines and curves that form the same profile on top of it. Essentially, its a single geoset with duplicate lines on lines. Is there a
tool in Catia (or custom macro) to isolate only one group of elements that form the profile without going thru each line and
deleting one of them?
thanks
K
Eric N.
indocti discant et ament meminisse periti
Great post! Report
Good suggestion to project, I discovered (after you create a smart join) you can project dumb up to the offset plane-
however, you must project along a direction and turn nearest solution off. That will (apparently) get rid of duplicate lines, I'm
not really sure WHY... but it worked so I'm happy.
http://www.eng-tips.com/viewthread.cfm?qid=395758 1/2
9/4/2017 Duplicate Line selection and deletion macro - DASSAULT: CATIA products - Eng-Tips
Home > Forums > Engineering Computer Programs > Engineering Programs > DASSAULT: CATIA products Forum
Advertise
http://www.eng-tips.com/viewthread.cfm?qid=395758 2/2