Académique Documents
Professionnel Documents
Culture Documents
1.CPU Parameters.........................................................................................................................2
3. Motherboard picture..............................................................................................................3
4. Motherboard Size.................................................................................................................... 5
Cores 2
Threads 4
Lithography 22nm
TDP 15W
Intel 64 Yes
USB 2*USB2.04*USB3.0
COM 0
3. Motherboard picture
4. Motherboard Size
5. BIOS Setting
At the time of Installed system or maintain test computer, can use the startup
disk to start, such as U rev, specific Settings can BOOT continuous press F11
shortcut menu Settings to start, turns on continuous press DEL into the BOOT
option select Hard drive BBS priorities > choose you to start the equipment.
Enter,F10preservatio.
Press F11 shortcut menu to start the startup, the diagram below:
7.Issue and Solution
7.1 There will be have a lots of issue during using PC period, OS will be the
Issue: the equipment does not power, but power light normal.
7.2 Issue: Boot into the system, notice that the system can not boot
Solution: Using the boot disk into the PE system to repair the system boot
(boot disk available U disk production, production tools are U master, computer
7.3 Issue: Boot the equipment, motherboard normal, power adapter normal, press
Solution: open the equipment case, and put the small battery out( one the
motherboard), use the screwdriver to Short-circuit positive and negative, and then
re-install the Ram, do not forget to put the small battery in.
Solution: Re-install OS
7.6 Issue: Connect the Lan cable, but can not USE.
Solution: Check if you have install driver, check the local connections if have
date, Whether to use the IP address and route allocation of a network segment, set
up with the same network segment routing static IP address, Re-install driver.
7.7 Issue: can not find the Wifi or poor wifi signal or with exclamation mark
Solution: Re-install wifi card driver, change the wireless mode compatibility
settings, set the static IP test, use the command (ipconfig / release release IP and
then ipconfig / renew to obtain IP address) to change the router channel, 1 and 2
7.8 Issue: Each boot will appear windows normal configuration, configuration
failure, is to restore changes, please turn off the power. For a long time can not
Solution: Wait for the update or restore the update is complete to enter the
system. You can restart the computer, press F8 to select network security mode or
security mode into the system. After entering the system, in the control panel, point
to open the windows update, the automatic update to close the problem can be
solved.