Académique Documents
Professionnel Documents
Culture Documents
The following boxed Videx power supplies which are covered: SP24, SP27, SP28, SP29 and SP30. It
should be noted that these power supplies are suitable for fixed installations only and for installations as
permanently connected equipment. They MUST NOT be connected externally.
First mount the power supply on a flat vertical surface in the correct orientation i.e. with the hinge
on the left hand side using the appropriate fixing screws.
The power supply should be installed to allow for maxium air movement where possible and avoid
areas with high humidity.
They should be mounted with a minimum of 100mm clearance between the sides and lid of the
power supply case and any adjacent wall, ceilling or other partition.
Switch OFF the mains using the circuit breaker mentioned previously on page 26 and then make the
connections as shown on the installation diagrams.
Check the connections and secure the load and all associated wiring observing the correct polarity
of the DC outputs (the cable size must be of sufficient size and rating to carry currents for all loads
connected to the power supply).
Any mains cables and low voltage cables should be routed separately to the power supply.
When all connections are made restore the mains.