Académique Documents
Professionnel Documents
Culture Documents
Regulation passed by the U.S. Department of Energy and the ballast directives adopted by the
European Community have urged the lighting industry to shift towards the use of more
The electronic ballast is an efficient electrical device that supplies a controlled current to start
and run fluorescent and high intensity discharge (HID) lamps. As electronic ballasts are
steadily becoming smaller, smarter and more flexible, they are poised to control the market.
Both fluorescent and HID lamp ballast applications will show improved performance,
flexibility and cost advantages when using Atmel microcontrollers over currently available
solutions.
The AT83EB5114 and AT90PWM ICs offer in a single package all the features needed in a linear
or dimmable fluorescent tube ballast, as well as in a HID ballast. They enable lighting products
with increased performance and efficiency, resulting in cost benefits and efficient housing.
Back Projection
Display Systems
Reduction of Ballast Component Count
z Factory calibrated RC oscillator, avoiding the use
of expensive crystals
Street and Monument Lighting z Integrated amplifiers
Network Voltage
*N/A on AT8xEB5114
Atmel Corporation
C51 AVR
2325 Orchard Parkway
San Jose, CA 95131 AT8xEB5114 AT90PWM1 AT90PWM2 AT90PWM3 AT90PWM216 AT90PWM316
USA
TEL.: 1 (408) 441-0311
Memory
FAX.: 1 (408) 487-2600 Flash (KB) 4 8 8 8 16 16
or
Regional Headquarters ROM (KB) 4
Europe EEPROM (bytes) 256 512 512 512 1024 1024
Atmel Sarl
Route des Arsenaux 41 RAM (bytes) 256 512 512 512 1024 1024
Case Postale 80
In-system Programming Capability
CH-1705 Fribourg
Switzerland SPI SPI SPI SPI SPI
Yes
TEL.: (41) 26-426-5555 Self programming Self programming Self programming Self programming Self programming
FAX.: (41) 26-426-5500
On-chip Peripherals
Asia
PWM Generators 2/-/2 1/2/1 1/2/1 1/3/1 1/2/1 1/3/1
Room 1219
Chinachem Golden Plaza (8-bit/12-bit/16-bit)
77 Mody Road Tsimshatsui PWM Channels 4 7 7 10 7 10
East Kowloon
Hong Kong 10-bit ADC 6-channel 8-channel 8-channel 11-channel 8-channel 11-channel
TEL.: (852) 2721-9778 Analog Comparator 2 2 3 2 3
FAX.: (852) 2722-1369
Amplifier Yes Yes Yes Yes Yes Yes
Japan
10-bit DAC Yes Yes
9F, Tonetsu Shinkawa Bldg.
1-24-8 Shinkawa Temperature Sensor Yes Yes
Chuo-ku, Tokyo 104-0033
Japan DALI/UART DALI/UART DALI/UART DALI/UART DALI/UART
TEL.: (81) 3-3523-3551 SPI Yes Yes Yes Yes Yes
FAX.: (81) 3-3523-7581
RC Oscillators 2 2 2 2 2 2
Web Site
PLL 64 MHz 64 MHz 64 MHz 64 MHz 64 MHz
http://www.atmel.com
Available Versions
Literature Requests
www.atmel.com/literature Power Supply (V) 3.0 - 3.6 2.7 - 5.5 2.7 - 5.5 2.7 - 5.5 2.7 - 5.5 2.7 - 5.5
Support avr@atmel.com