Académique Documents
Professionnel Documents
Culture Documents
October 2007
Markets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .All
Background information
Replace the original seat with a replacement which includes increased thickness foam for improved rider
comfort. The foam thickness has been increased at both sides of the riders seat, to address in-service feedback
concerning rider comfort after long distances.
Other Instructions
Once completed, please mark the service record book that the requirements of this bulletin have been
complied with.
Replacement Procedure
Replace following the procedure listed below:
Warning
Throughout the following procedure, ensure that the motorcycle is stabilised and adequately supported to
prevent the risk of injury from the motorcycle falling.
Removal
1. The seat lock is located on the left hand side of the battery tray, in line with the footrest mounting rail. To
remove the seat, insert the ignition key into the seat lock and turn it anti-clockwise while pressing down on
the rear of the seat. This will release the seat from its lock and allow it to be slid rearwards for complete
removal from the motorcycle.
cdmh
1. Seat lock
2. Remove the Owners Handbook wallet from its location in the seat base.
2
celg 3
1. Fuel tank support
2. Seat base
3. Allen key
Installation
1. Refit the fuel tank support and allen key to their respective locations on the new seat base.
2. Clip the Owners Handbook wallet to the new seat base, after marking the service record book that the
requirements of this bulletin have been complied with.
3. To refit the seat, engage the seat's tongue under the fuel tank and press down at the rear to engage in the
seat lock.
Warning
To prevent detachment of the seat during riding, after fitting always grasp the seat and pull firmly upwards. If
the seat is not correctly secured it will detach from the lock. A loose or detached seat could cause loss of
motorcycle control and an accident.
Circulation
(Initial and date when read and return to central file holder)