Académique Documents
Professionnel Documents
Culture Documents
Very fast shipping, accurate package and excellent quality products, many thanks! I have chosen to stick with my original and am just keeping an
eye on it. Lighter and stronger than I would have guessed. So if you end up with a little grease or oil on your hands the manual is not ruined. They
changed the tail pulley to incorporate their new stronger design as well. Make sure you are ready if you decide to fly your Goblin at rpm. This was
a big help for me since I normally spend hours staring at a heli trying to decide where to run the wires. SAB has also changed the design of a
couple pulleys. Then I cut the shaft off using Dremel with the cut off disc. I did notice that after the first few flights I had some binding there again. If
u can afford higher dollar equipment go kontronic. The ability of the Goblin to fly slow, fast, hard, soft, precision and smack are just mind boggling.
I have had great success with this combo. Whats funny is the OP never listed kontronic as an esc choice but everyone says buy it. The
transmission is another possibility. Goblin Motor and ESC! Here you need to decide if you are going to fly sport or 3d. I was afraid they would
allow too much flex, but so far have proven to be perfect. My helicopter came in at The distance should be at least mm. I pulled the canopy off to
see the flames coming from the ESC and over the two 6s mah batteries and the Kontronik motor. I screwed it in by hand, then used green Loctite
to secure it in permanently. I finished this with a small piece of sandpaper and needle file in the areas where the sanding drum could not reach. No,
that too has been done. Be sure to install the balls and servo arms prior to installing the servos. Electronic installation was easier on this heli than
others I have done. Representative APR variable Just make sure you run KSA mode. Now that I have owned, serviced and flown the Goblin for a
while I wanted to update everyone on how things have went. Now that is faith in design and manufacturing. Watch list is full. Please enter a valid
email address for yourself. Originally Posted by justindewoody. Just looking at the outside of the manual is another sign that you are dealing with a
quality product. So far it is still bonded well. Add to Watch list Watching. One of the things they preassembled was the bearings in the various
parts throughout the kit. I commend SAB on acknowledging that some things could be better, taking the proper steps to improve those things, then
finally to publicly inform everyone of the changes and updated parts. That was at rpm head. I would say if you are looking for a sized stick banging
sickly overpowered machinethen look no farther. If it makes you feel better I just blew up 2 Hobbywing HV's with a new mx. Both the
Kontronik and the Quantum bolted right up without issue. Of course the truth is obvious. Thank you SAB for designing a fantastic machine, and
thank you HeliDirect for the opportunity to do this review. They have a tray for the ESC that also acts as a heat sink. This includes the landing
gear, battery tray and front of the frames. So chances are it was moving around mph. I had several Pro pilots fly it to get their impressions. I put
some grease on the gears to help break them in properly. I got out my Dremel with a small round sanding cylinder.