Académique Documents
Professionnel Documents
Culture Documents
NEED TO CHANGE RADIO & MMU AT BOTH END AND FREQUENCY AND MODULATION CHANGE BETWEEN BA0178 TO BA0012 FOR FDD
NEW RADIO
BA0012:- CR9H933809
BA0015:- A2310FG1SH
VLAN WILL BE ROUTED FROM HUB SITE FOR FDD AND PING TEST WILL BE DONE
PQ TRA ATTACHED
IMPLEMENTOR NAME:-
1. Robin Thomas,
2. Mohammad Naushad,
3. Lasin C Suresh
4. Sharique,
5. Mishra
AT BA0012
AT BA0178
COMMON ACTIVITY
1. We will configure the VLAN ID as per IP Plan up to the HUB site of the transmission chain
2. We will take ping test for the particular VLAN ID from local site, if port is free (mention TN port information)
3. After completing ping test team will revert back port status as precious
4. Untag the VLAN as previous
5. Team will not do any trouble shooting if Vlan id is not working
6. We will check DCN connectivity if it has configured in old traffic node and working
7. After completing any Ethernet configurations changes, go to CLI mode and run "write" command to save configurations. Afterwards
run "show confirm timer" command. If it returns confirm timer is not running!, it means confirmation was saved successfully.
Otherwise save configurations again and dont disconnect from nodeuntil configurations are saved.
MU0254-A2310BDZWQ,A2310BDYEW
MU0053-A2310A6X69,A2310A70VG
1. if MMU3A has some issue, team will take out card and restore the sites
2. if upgrade will make issue with other cards or active traffic, team will try to resolve the issue and if not possible, team will back to
old running software in node.
3. if any new PIU has some issue, team will take out card and restore the sites
4. In case of any interference with new frequency, team will inform to planning team and will stop our activity.
5. If there is huge difference in RSL, activity will revert back
6. Rollback to old configuration if anything goes wrong in TN
7. if any new critical alarm will appear and would not solve during the activity, will revert back the activity
8. If there is any mismatch in license, will revert back the activity and will inform to concern Ericsson person.
9. We will delete all newly added VLAN ID if there will be any loop in network because of new VLAN ID