Vous êtes sur la page 1sur 6

TOS/SOM www.aarekh.

com

1. Ratio of length of column to the minimum radius of gyration of the cross sectional area of the column is
known as [SSC JE 2014]
(A) Slenderness ratio (B) buckling ratio
(C) crippling ratio (D) compressive ratio

2. The effective slenderness ratio of a cantilever column is [SSC JE 2014]


(A)0.5L/r (B) L/r
(C) 2L/r (D) 2L/r

3. The slenderness ratio of a column is zero when its length: [SSC JE 2013]
(A) effective length is equal to actual length
(B) is very large
(C) is equal to its radius of to gyration
(D) is supported on all side throughout its length

4. Compression members always tend to buckle in the direction of the [SSC JE 2013]
(A) least radius of gyration (B) axis of load
(C) perpendicular to the axis of load (D) minimum cross-section

5. Bucking load for an axially loaded column with both ends fixed is given by [SSC JE 2013]

6. Eulers formula is valid for : [SSC JE 2010]


A) short column only
B) long column only
C) both short and long column
D) none of the above

7. The equivalent length of a column of length L having both ends fixed as given by: [SSC JE 2012]
A) 2L
B) L
C) L/2
D) L/ 2

8. Two beams one of circular cross section and the other of square cross section have equal
areas of cross section .if subjected to bending , then [SSC JE 2012]
A) circular cross section is more economical
B) square cross section is more economically
C) Both sections are equally economically
D) both sections are equally stiff

9. The allowable stress in a long column can be increased by increasing the : [SSC JE 2012]
A) radius of gyration
B) eccentricity
C) slenderness ratio
D) length of the column
TOS/SOM www.aarekh.com

10. which one of the following factors does not affected the lateral buckling strength of a steel I section
undergoing bending about its major axis? [SSC JE 2012]
A) Boundary conditions at the ends
B) Radius of gyration about the minor axis of the sections
C) Laterally unsupported length of the compression flange
D) Radius of gyration about the major axis of the section

11.

[SSC JE 2005]

12.

[SSC JE 2010]

Answers :- 1. (A), 2. (D), 3. (D), 4. (A), 5. (C), 6. (B), 7. (C), 8. (B) 9. (A), 10. (B)

Vous aimerez peut-être aussi