Académique Documents
Professionnel Documents
Culture Documents
Page 1 of 1
All Databases PubMed Nucleotide Protein Genome Structure OMIM PMC Journals Books
All: 1 Review: 0
Related articles
Geotechnical engineering properties of incinerator ash mixes. Performance evaluation of cement stabilized fly ash-
GBFS mixes as a highway construction
[Waste
material.
Manag. 2008]
Muhunthan B, Taha R, Said J. Laboratory compaction of fly ash and fly ash with
cement additions. [J Hazard Mater. 2008]
Department of Civil and Environmental Engineering, Washington State University, Pullman,
Washington 99164-2910, USA. muhuntha@wsu.edu Recovery of municipal waste incineration bottom ash
and water treatment sludge to water[Waste
permeable
Manag. 2006]
The incineration of solid waste produces large quantities of bottom and fly ash.
Review The potential of recycling and reusing municipal
Landfilling has been the primary mode of disposal of these waste materials.
Shortage in landfill space and the high cost of treatment have, however, prompted solid waste incinerator ash in Taiwan.
[Waste Manag. 2006]
the search for alternative uses of these waste materials. This study presents an Review Possible applications for municipal solid waste
experimental program that was conducted to determine the engineering properties fly ash. [J Hazard Mater. 2003]
of incinerator ash mixes for use as construction materials. Incinerator ash mixes
were tested as received and around optimum compacted conditions. Compaction See reviews... | See all...
curves, shear strength, and permeability values of fly ash, bottom ash, and their
various blends were investigated. Bottom ash tends to achieve maximum dry Recent Activity
density at much lower water content than does fly ash. The mixes displayed a
change in their cohesion and friction angle values when one of the two mix
Turn Off Clear
components was altered or as a result of the addition of water. The permeability of
bottom ash is quite comparable to that of sand. The permeability of fly ash lies in
the range of those values obtained for silts and clays. A 100% bottom ash Geotechnical engineering properties of
compacted at the optimum water content has a lower density value and yields a incinerator ash mixes.
higher friction angle and cohesion values than most construction fills. This would
encourage the use of bottom ash as a fill or embankment material because free
drainage of water will prevent the buildup of pore water pressures.
PMID: 15373366 [PubMed - indexed for MEDLINE]
http://www.ncbi.nlm.nih.gov/pubmed/15373366?log$=activity 06/04/2009