Académique Documents
Professionnel Documents
Culture Documents
GENERAL SPECIFICATIONS
* 110-440 Volt Supply
* 5 Digit 7 segment red Led display
* 5 pcs status LED
* 4 push buttons,
* 4 pcs general use 3 pin (NC/NO/Com) relays
* High resolution ∑-∆ ADC
* Min 70Ω loadcell input ,
* RS232C (PC-PLC-Printer- External display),
* 0~5 V / Analog output.
* RF Communication (Optional)
BUTTON FUNCTIONS
ZERO Zeroing button, for zeroing the weight. Used for: Down button
AŞAĞI in menus, decreasing the values, changing between
TUŞ parameters.
FONKSİYON Function button., Used for ;Entering parameter menu, up
YUKARI button in menues, increasing the values, changing between
TUŞ parameters.
ESC Escape button. Used for ; shifting the value to next digit and
YAZDIR add a zero at the and in parameters. Printer button while in
TUŞ communication mode.
ENTER Enter button. Entering calibration, confirming inputted values,
TUŞU saving and going through next steps in menues.
Table 1.1
St Stable led Constantly lights up when weighing data is stable,
otherwise blinks.
Sp1 Relay 1 Lights up and switches the relay outputs if relay 1 set value
Status LED has reached
Sp2 Relay 2 Lights up and switches the relay outputs if relay 2 set value
Status LED has reached
Sp3 Relay 3 Lights up and switches the relay outputs if relay 3 set value
Status LED has reached
Sp4 Relay 4 Lights up and switches the relay outputs if relay 4 set value
Status LED has reached
Table1.2
CALIBRATION :
After entering the calibration menu “ CAL x” will appear on the display. You can select
between different calibration options with up and down buttons or quit with esc button. Enter
will let you pass the next steps.
Kalibrasyon menusüne girdikten sonra ekranda "Cal x) yazacaktır.Kullanılacak olan
Kalibrasyon yöntemi "Yukarı" ve "Aşağı" ok buton tuşları yardımıyla seçilir ve enter tuşuna
basarak onaylanır.
NO DISPLAY OPTION DESCRIPTION
1 "Cal 1" Calibration
with
refference
load
2 Milivolt
"Cal 2" calibration
You can calibrate OLT-A with your load cells output value
2 RELAY -1 "ENTER"
"ESC"
3 RELAY -2 "ENTER"
"ESC"
4 RELAY -3 "ENTER"
"ESC"
5 RELAY -4 "ENTER"
"ESC"
When you press enter, display will show you current set value of the selected relay.
Please use up,down, and esc buttons to determine the set value and press ENTER to finish the
settings.
SET 2 (ANALOG OUTPUT SETTINGS)
You can adjust an analog output according to your capacity and current load
Please follow these steps
OLT-A has built in RS232-RS232c features. Baud rate, device selections can be set
through this menu by following these steps.