vary
telay to relay and more specifically is
dependent on the primary earth faut
‘ument sting requirement
EARTH CURRENT SETTING
"thas been common practice to specify the
asf the current vansfrmer i ine with
SIGS. speciyng relerence votages at
‘axing accuracy limit factors, this however
oes not ensure that the transformer wl
have sufficient voltage output at the
required operating feel — ie. a current
transformer specited with an acciracy tt
factor of 5 wil ensue that it has the
‘required output at 5 ties rated Curent,
however, ifthe eath curtent setting is 20%
of rated cutent then itis esentil thatthe
‘ranstormer has the requires votage ouput
at this level if the characteristics of the
‘magnetic matenal in the cre Would be
linear then this would not represent >
problem, however, the majority of magnetic
Materials Fove the charectricics of a9
inverse knee point at very low values of
fexoting current, for Wi razon thatthe
‘design must be checkee at al the possible
ested operating level settings.
DN
Sy
[REGRESSIVE WINDING METHOD
‘An established solutions the uation ofa
‘eoressive winding method in winding the
CCT; this was fest invented by Sten later
refined by Goss. This system does not
completely neutralise tures set up in the
corey eternal ld 0 itis essen t a
anes this problem
SCREENING SOLUTION
A solution which as provided excelent
resis isthe total screening of wining and
cores wth fu nes essentially these can
consist of 2 concentne butler of low
permeabiity materal onthe internal