Académique Documents
Professionnel Documents
Culture Documents
Generator Set
with PowerCommand 3100, Detector and Sentinel
Controller
English
Original Instructions 12-2015 960−0210 (Issue 8)
This catalog covers models produced under the The following symbols are used in Cummins Power
Cummins/Onan and Cummins Power Genera- Generation manuals to alert users to the potentially
tion brand names. dangerous conditions relating to maintenance of
equipment and replacement of parts. Please read
To avoid errors or delay in filling your parts order, al-
and observe.
ways give the MODEL, SPEC NO. and SERIAL NO.
from the Cummins Power Generation nameplate. This symbol warns of immediate
hazards which will result in severe
For handy reference, insert your nameplate in-
personal injury or death.
formation in the spaces below.
This symbol refers to a hazard or
MODEL AND SPEC NO. unsafe practice which can result
in severe personal injury or death.
SERIAL NO.
This symbol refers to a hazard or
unsafe practice which can result
DIGITAL CONTROL SOFTWARE VERSION in severe personal injury or prod-
AND DATE (IF APPLICABLE) uct or property damage.
Service and repair of Cummins Power Generation equipment must be performed by trained, experienced
personnel only. Improper service or repair may result in property damage, severe personal injury or
death. Do not use this catalog as a guide to servicing your equipment. Read and follow the IMPORTANT
SAFETY INSTRUCTIONS in the Service Manual appropriate for the equipment you are working on.
Contact with USED ENGINE OILS has been identified by a United States federal agency and some USA
state agencies as causing CANCER or REPRODUCTIVE TOXICITY. When checking or changing engine
oils take all necessary precautions not to ingest, breathe the fumes or contact the used oil.
Contact with ASBESTOS has been identified by a United States federal agency and some USA state agen-
cies as causing CANCER or REPRODUCTIVE TOXICITY. When handling engine gaskets take all neces-
sary precautions not to ingest, breathe or contact the dust from the gaskets! Use adequate ventilation
and wear protective gloves, masks and clothing!
Contact with BENZINE and LEAD, found in gasoline, fuel additives and solvents has been identified by
a United States federal agency and some USA state agencies as causing CANCER or REPRODUCTIVE
TOXICITY. When checking, draining or adding gasoline and fuel additives or using solvents take all nec-
essary precautions not to ingest, breathe the fumes or contact the liquids. Use adequate ventilation and
wear protective gloves, masks and protective clothing!
PSP-1
This catalog applies to the standard generator models DGBB, DGBC, DGCA, DGCB and DGCC as listed
in the Generator Set Data Table. Parts are arranged in groups of related items and each illustrated part is
identified by a reference number corresponding to the same reference number in the parts list. Parts illustra-
tions are typical. Unless otherwise mentioned in the description or page heading, parts are interchangeable
between models. Throughout this catalog left and right sides are determined by facing the engine end (front)
of the set.
Engine parts that have been modified or added by Cummins Power Generation are identified in this catalog.
All other engine replacement parts must be ordered from the engine manufacturer by referring to the engine
manufacturer’s nameplate and supplying all available information. Contact your nearest engine parts distrib-
utor for assistance in ordering replacement parts.
Replacement Engine
* − The Specification number denotes customer requested options or deviations from the standard model.
The specification letter advances with major manufacturing changes.
Block, Terminal − Generator, 103 Bracket, Overflow Bottle − DGBB Spec F, DGBC
Spec E, DGCA and DGCB Spec N, DGCC
Block, Terminal − Generator Heater (Quiet Site), Spec A, B, 60
101
Bracket, Overflow Tank − DGBB Spec G−J,
Block, Terminal − Generator Heater (Standard), DGBC Spec F−H, DGCA, DGCB Spec P−S,
100 61
Bracket, Overspeed − Mechanical, 110 Cable, Battery − Sets With Sentinel Control −
DGBB Spec D−G, DGBC Spec C−F, DGCA
Bracket, Pump − Subbase Fuel Tank, 34 and DGCB Spec L−P, DGCC Spec A, 12
Breaker, Circuit − AC − Fuel Tank Control, 36 Cable, Battery − Sets With Sentinel Control −
DGBB Spec H, DGBC Spec G, DGCA and
Breaker, Circuit − DC − Fuel Tank Control, 36
DGCB Spec R, 13
Breaker, Circuit − Non−UL Listed − DGBB Spec Cable, Heater − Control Heater − Sets With De-
D, DGBC Spec C, DGCA and DGCB Spec L, tector Control, 108
149
Cable, Heater − Oil Heater, 52
Breaker, Circuit − Sentinel Control, 115
Cap, Fill − In−Skid Fuel Tank, 33
Breaker, Circuit − UL Listed − DGBB Spec D,
DGBC Spec C, DGCA and DGCB Spec L, Cap, Fill − Subbase Fuel Tank, 32
148 Cap, Radiator − DGBB Spec D−F, DGBC Spec
C−E, DGCA, DGCB Spec L−N, DGCC Spec
Breaker, Circuit − UL Listed, IEC Conformity − A, B, 55
DGBB Spec E, DGBC Spec D, DGCA and
DGCB Spec M, 150 Cap, Radiator − DGBB Spec G−J, DGBC Spec
F−H, DGCA, DGCB Spec P−S, 57
Breaker, Circuit − UL Listed, IEC Conformity −
DGBB Spec F−J, DGBC Spec E−H, DGCA Cap, Vent − Subbase Fuel Tank, 32
and DGCB Spec N−S, DGCC Spec A, B, 152 Cartridge, Heater − Generator (Quiet Site), 101
Cartridge, Heater − Generator (Standard), 100
Breaker, Circuit − Voltage Regulator − Sets With
Clamp, Stator − PMG, 113
Detector Control, 128
Cleaner, Air − DGBB, DGBC, 30
Breaker, Circuit − Voltage Regulator − Sets With
Sentinel Control, 129 Cleaner, Air − DGCA, DGCB, DGCC, 31
Bulb, Replacement − Emergency Stop Switch, Contact, Auxiliary − DGBB Spec D, DGBC Spec
130 C, DGCA and DGCB Spec L, 147
Contact, Dry − DGBB Spec F−J, DGCA and
DGCB Spec N−S, DGCC Spec A, B, 119
F
D Fan, Alternator, 89
Diode − Generator, 103 Fan, Radiator − DGBB Spec D−F, DGBC Spec
C−E, DGCA, DGCB Spec L−N, DGCC Spec
Disc, Drive − Generator, 105
A, B, 55
Door, Control − Detector Control, 117
Fan, Radiator − DGBB Spec G−J, DGBC Spec
Drain, Coolant − DGBB Spec G−J, DGBC Spec F−H, DGCA, DGCB Spec P−S, 57
F−H, DGCA, DGCB Spec P−S, 59 Filter, Screen − Fuel − Float Valve, 37
Drain, Oil − Extension, 29 Fuse − Sentinel Control, 115
E G
Edging − Control Housing, 92 Gasket, Cover Plate − Float Valve, 37
Element, Cleaner − Air − DGBB, DGBC, 30 Gasket, Drain − Oil Pan, 29
Element, Cleaner − Air − DGCA, DGCB, DGCC, Gasket, Exhaust − DGBB, DGBC, 40
31 Gauge, Fuel Level − In Skid Fuel Tank, 33
External Engine Parts − Sets With Detector Con- Gauge, Fuel Level − Subbase Fuel Tank, 32
trol − DGBB Spec D−G, DGBC Spec C−F,
DGCA and DGCB Spec L−P, DGCC Spec A, Gauge, Oil Temperature − DGBB Spec D, DGBC
16 Spec C, DGCA and DGCB Spec L, 144
External Engine Parts − Sets With Detector Con- Gauge, Pressure − Oil − Sets With Detector Con-
trol − DGBB Spec H, DGBC Spec G, DGCA trol, 117
and DGCB Spec R, 19 Gauge, Pressure − Oil − Sets With Sentinel Con-
trol, 28
External Engine Parts − Sets With Detector Con-
trol − DGBB Spec J, DGBC Spec H, DGCA Gauge, Temperature − Water − Sets With Detec-
and DGCB Spec S, DGCC Spec B, 21 tor Control, 117
Gauge, Temperature − Water − Sets With Senti- Harness, Wiring − Engine To Control − Sets With
nel Control, 28 PowerCommand Control − DGBB Spec D, E,
DGBC Spec C, D, DGCA and DGCB Spec L,
Generator, 103 M, 121
Governor, Electronic − DGBB Spec D, E, DGBC Harness, Wiring − Engine To Control − Sets With
Spec C, D, DGCA and DGCB Spec L, M, PowerCommand Control − DGBB Spec F, G,
DGCC Spec A, 90 DGBC Spec E, F, DGCA and DGCB Spec N,
Governor, Electronic − DGBB Spec F−J, DGBC P, DGCC Spec A, 123
Spec E−H, DGCA and DGCB Spec N−S, Harness, Wiring − Engine To Control − Sets With
DGCC Spec B, 91 PowerCommand Control − DGBB Spec H, J,
Grille, Radiator − DGBB Spec D−F, DGBC Spec DGBC Spec G, H, DGCA and DGCB Spec R,
C−E, DGCA, DGCB Spec L−N, DGCC Spec S, DGCC Spec B, 125
A, B, 55 Harness, Wiring − Fuel Alarm − DGBB Spec F,
DGCA and DGCB Spec N, 136
Grille, Radiator − DGBB Spec G−J, DGBC Spec
F−H, DGCA, DGCB Spec P−S, 57 Harness, Wiring − Fuel Tank Control, 36
Guard, Belt − Remote Radiator, 53 Harness, Wiring − In−Skid Fuel Tank Pump to
Control, 35
Guard, Fan − Generator, 103
Harness, Wiring − Low Battery Voltage, 141
Harness, Wiring − Low Coolant Level Sender −
H With Continuously Monitored Low Coolant
Level, 48
Harness, Wiring − AC − Sets With Detector Con- Harness, Wiring − Low Coolant Level Sender −
trol, 117 Without Continuously Monitored Low Coolant
Level − DGBB Spec D, E, DGBC Spec C, D,
Harness, Wiring − AC Auxiliary, 127 DGCA and DGCB Spec L, M, 49
Harness, Wiring − AC Control − Sets With Senti- Harness, Wiring − Low Coolant Level Sender −
nel Control, 129 Without Continuously Monitored Low Coolant
Level − DGBB Spec F−J, DGBC Spec E−H,
Harness, Wiring − Alarm Relay Board, 131 DGCA and DGCB Spec N−S, DGCC Spec A,
Harness, Wiring − Common Alarm, 132 B, 50
Harness, Wiring − DC − Sets With Detector Con- Harness, Wiring − Meter Transformer, 146
trol, 117 Harness, Wiring − Over/Under Frequency Relay −
Harness, Wiring − Dry Contact − DGBB Spec DGBB Spec D, DGBC Spec C, DGCA and
F−J, DGCA and DGCB Spec N−S, DGCC DGCB Spec L, 140
Spec A, B, 119 Harness, Wiring − Over/Under Voltage − DGBB
Spec D, DGBC Spec C, DGCA and DGCB
Harness, Wiring − Electric Overspeed − Sets With
Spec L, 138
Detector Control, 111
Harness, Wiring − PMG, 113
Harness, Wiring − Electric Overspeed − Sets With
Sentinel Control, 112 Harness, Wiring − Subbase Fuel Tank Pump to
Control, 34
Harness, Wiring − Electronic Governor − DGBB
Spec D, E, DGBC Spec C, D, DGCA and Harness, Wiring − Time Delay Start/Stop, 139
DGCB Spec L, M, DGCC Spec A, 90 Harness, Wiring − Wattmeter − DGBB Spec D,
Harness, Wiring − Electronic Governor − DGBB DGBC Spec C, DGCA and DGCB Spec L,
Spec F−J, DGBC Spec E−H, DGCA and 142
DGCB Spec N−S, DGCC Spec B, 91 Heater Assembly, Control − Sets With Power-
Harness, Wiring − Engine to Control − Detector Command Control, 109
Control, 127 Heater, Control − Sets With Detector Control, 108
Harness, Wiring − Engine to Control − Sentinel
Control, 127 Heater, Engine Coolant, 51
Isolator, Vibration − Detector Control, 117 Muffler − Standard − DGBB Spec E−J, DGBC
Spec D−H, DGCA and DGCB Spec M−S,
Isolator, Vibration − Sentinel Control, 115 DGCC Spec A, B, 46
Rectifier, Power − Control Heater − Sets With De- Sender, Low Engine Temperature − Sets With
tector Control, 108 PowerCommand Control − DGBB Spec J,
DGBC Spec H, DGCA and DGCB Spec S,
Rectifier, Silicon − Low Coolant Level Sender − DGCC Spec B, 27
With Continuously Monitored Low Coolant
Level, 48 Sender, Oil Pressure − Sets With Detector Con-
trol − DGBB Spec D−G, DGBC Spec C−F,
Regulator, Voltage − Sets With Detector Control, DGCA and DGCB Spec L−P, DGCC Spec A,
128 16
Sender, Oil Pressure − Sets With Detector Con- Skid − Basic − DGBB Spec D, DGBC Spec C,
trol − DGBB Spec H, DGBC Spec G, DGCA DGCA and DGCB Spec L, 78
and DGCB Spec R, 19
Skid − Basic − DGBB Spec E−J, DGBC Spec
Sender, Oil Pressure − Sets With Detector Con- D−H, DGCA and DGCB Spec M−S, DGCC
trol − DGBB Spec J, DGBC Spec H, DGCA Spec A, B, 80
and DGCB Spec S, DGCC Spec B, 21 Skid − Housing Ready/Fuel Tank Ready − DGBB
Sender, Oil Pressure − Sets With PowerCom- Spec D, DGBC Spec C, DGCA and DGCB
mand Control − DGBB Spec D−G, DGBC Spec L, 79
Spec C−F, DGCA and DGCB Spec L−P, Skid − Housing Ready/Fuel Tank Ready − DGBB
DGCC Spec A, 22 Spec E−J, DGBC Spec D−H, DGCA and
Sender, Oil Pressure − Sets With PowerCom- DGCB Spec M−S, DGCC Spec A, B, 81
mand Control − DGBB Spec H, DGBC Spec Starter, 88
G, DGCA and DGCB Spec R, 25
Stator, Exciter, 105
Sender, Oil Pressure − Sets With PowerCom-
mand Control − DGBB Spec J, DGBC Spec Stator, Generator, 106
H, DGCA and DGCB Spec S, DGCC Spec B, Stator, PMG, 113
27
Strap, Ground − Detector Control, 117
Sender, Oil Temperature − Sets With PowerCom-
mand Control − DGBB Spec D−G, DGBC Switch, Basin − Basin Alarm, 39
Spec C−F, DGCA and DGCB Spec L−P, Switch, Basin − Low Fuel Alarm, 38
DGCC Spec A, 22
Switch, Emergency Stop, 130
Sender, Oil Temperature − Sets With PowerCom-
mand Control − DGBB Spec H, DGBC Spec Switch, Float − In−Skid Fuel Tank, 35
G, DGCA and DGCB Spec R, 25 Switch, Float − Subbase Fuel Tank, 34
Sender, Oil Temperature − Sets With PowerCom- Switch, High Water Temperature − Sets With De-
mand Control − DGBB Spec J, DGBC Spec tector Control − DGBB Spec D−G, DGBC
H, DGCA and DGCB Spec S, DGCC Spec B, Spec C−F, DGCA and DGCB Spec L−P,
27 DGCC Spec A, 16
Sender, Temperature − Oil Gauge − DGBB Spec Switch, High Water Temperature − Sets With De-
D, DGBC Spec C, DGCA and DGCB Spec L, tector Control − DGBB Spec H, DGBC Spec
144 G, DGCA and DGCB Spec R, 19
Sender, Water Temperature − Sets With Detector Switch, High Water Temperature − Sets With De-
Control − DGBB Spec D−G, DGBC Spec tector Control − DGBB Spec J, DGBC Spec
C−F, DGCA and DGCB Spec L−P, DGCC H, DGCA and DGCB Spec S, DGCC Spec B,
Spec A, 16 21
Sender, Water Temperature − Sets With Detector Switch, High Water Temperature − Sets With
Control − DGBB Spec H, DGBC Spec G, Sentinel Control − DGBB Spec D−G, DGBC
DGCA and DGCB Spec R, 19 Spec C−F, DGCA and DGCB Spec L−P,
DGCC Spec A, 12
Sender, Water Temperature − Sets With Detector
Control − DGBB Spec J, DGBC Spec H, Switch, High Water Temperature − Sets With
DGCA and DGCB Spec S, DGCC Spec B, 21 Sentinel Control − DGBB Spec H, DGBC
Spec G, DGCA and DGCB Spec R, 13
Sensor, Low Battery Voltage, 141 Switch, High Water Temperature − Sets With
Sentinel Control − DGBB Spec J, DGBC
Sensor, Speed − Electronic Governor − DGBB Spec H, DGCA and DGCB Spec S, DGCC
Spec F−J, DGBC Spec E−H, DGCA and Spec B, 15
DGCB Spec N−S, DGCC Spec B, 91
Switch, Overspeed − Mechanical, 110
Shroud, Radiator − DGBB Spec D−F, DGBC
Spec C−E, DGCA, DGCB Spec L−N, DGCC Switch, Pressure − Oil − Sets With Detector Con-
Spec A, B, 55 trol − DGBB Spec D−G, DGBC Spec C−F,
DGCA and DGCB Spec L−P, DGCC Spec A,
Signal, Audible, 134 16
Switch, Pressure − Oil − Sets With Detector Con- Transformer, Current, 145
trol − DGBB Spec H, DGBC Spec G, DGCA
and DGCB Spec R, 19 Transformer, Meter, 146
Switch, Pressure − Oil − Sets With Detector Con- Tray, Battery − Standard − DGBB Spec D−G,
trol − DGBB Spec J, DGBC Spec H, DGCA DGBC Spec C−F, DGCA and DGCB Spec
and DGCB Spec S, DGCC Spec B, 21 L−P, DGCC Spec A, B, 84
Switch, Pressure − Oil − Sets With Sentinel Con- Tray, Battery − Standard − DGBB Spec H, J,
trol − DGBB Spec D−G, DGBC Spec C−F, DGBC Spec G, H, DGCA and DGCB Spec R,
DGCA and DGCB Spec L−P, DGCC Spec A, S, 86
12 Tray, Battery − Tank Ready − DGBB Spec D−J,
Switch, Pressure − Oil − Sets With Sentinel Con- DGBC Spec C−H, DGCA and DGCB Spec
trol − DGBB Spec H, DGBC Spec G, DGCA L−S, DGCC Spec A, B, 85
and DGCB Spec R, 13 Trip, Shunt − UL Listed − DGBB Spec D, DGBC
Switch, Pressure − Oil − Sets With Sentinel Con- Spec C, DGCA and DGCB Spec L, 148
trol − DGBB Spec J, DGBC Spec H, DGCA Trip, Shunt − UL Listed, IEC Conformity − DGBB
and DGCB Spec S, DGCC Spec B, 15 Spec E, DGBC Spec D, DGCA and DGCB
Switch, Rocker − Detector Control, 117 Spec M, 151
Switch, Rocker − Fuel Tank Control, 36 Trip, Shunt − UL Listed, IEC Conformity − DGBB
Spec F−J, DGBC Spec E−H, DGCA and
Switch, Rocker − Sentinel Control, 115 DGCB Spec N−S, DGCC Spec A, B, 153
Switch, Rotary − Detector Control, 117
Tube, Water Heater, 51
T V
Tank, Fuel − In−Skid, 33
Valve, Float, 37
Tank, Fuel − Subbase, 32
Valve, Shutoff − Oil Drain, 29
Tank, Overflow − DGBB Spec G−J, DGBC Spec
F−H, DGCA, DGCB Spec P−S, 61 Valve, Shutoff − Radiator − DGBB Spec D−F,
DGBC Spec C−E, DGCA, DGCB Spec L−N,
Thermostat, Pre Water Temperature − Sets With DGCC Spec A, B, 55
Detector Control − DGBB Spec D−G, DGBC
Spec C−F, DGCA and DGCB Spec L−P, Valve, Solenoid − Float Valve, 37
DGCC Spec A, 16
Varistor − Generator, 103
Thermostat, Pre Water Temperature − Sets With
Detector Control − DGBB Spec H, DGBC Voltage, Over/Under − DGBB Spec D, DGBC
Spec G, DGCA and DGCB Spec R, 19 Spec C, DGCA and DGCB Spec L, 138
Thermostat, Pre Water Temperature − Sets With Voltmeter − Detector Control, 117
Detector Control − DGBB Spec J, DGBC
Spec H, DGCA and DGCB Spec S, DGCC
Spec B, 21 W
Transducer, Watts − DGBB Spec D, DGBC Spec
C, DGCA and DGCB Spec L, 142 Wattmeter − DGBB Spec D, DGBC Spec C,
DGCA and DGCB Spec L, 142
Transformer − Voltage Regulator − Sets With
Sentinel Control, 129 Wrapper, Control − Sentinel Control, 115
Some of the following abbreviations may be used throughout this Parts Catalog:
AC Alternating Current mm Millimeter
Amp Ampere MOH Mobile Off Highway
A/R As Required NFS Not For Sale
AVR Automatic Voltage Regulator NPT National Pipe Thread
AWG American Wire Gauge OD Outside Diameter
Deg Degree oz. Ounce
DC Direct Current PMG Permanent Magnet Generator
EFC Electronic Fuel Control Ph Phase
ET External Tooth PC Printed Circuit
EIT External/Internal Tooth RFI Radio Frequency Interference
GFI Ground Fault Interrupter RT Right
ID Inside Diameter Spec Specification
IT Internal Tooth Thk Thick
IEC International Electrotechnical UL Underwriters Laboratories Inc.
Commission UNC Union National Coarse
kW Kilowatt UNF Union National Fine
LPG Liquid Petroleum Gas VAC Volts Alternating Current
LT Left VDC Volts Direct Current
M(meter Number) Meter W/(ET, IT, EIT) With
11
1
3
7
1
3
5
6 9
10
3
6
10 10
11 11
12 12
13 13
14 16
15
17 4
1
3
6
1
3
5
5 8
9
11
12
13 3
19 7
10 20 10
11 11
12 12
13 13
14 16
15
17 4
1
3
7
1
3
6
6 18
9
13
14
15 5
16
8
12 3
2
10
1
4
1
4 6
11 17
7 18
1 856−0013 2 Washer, Lock − EIT (1/2) 9 309−0641−19 1 Switch, Pressure − Oil (S1)
2 800−2085 1 Screw, Cap − Hex Head 10 332−2921 1 Clamp, J
(M10 x 1.5 x 25) 11 526−2140 1 Washer, Flat (M12)
3 309−0554−01 1 Switch, High Water 12 309−0553−01 1 Thermostat (Pre Water
Temperature (S2) Temp) (S6)
4 800−2111 2 Screw, Cap − Hex Head 13 193−0375 1 Sender, Water Temperature
(M12 x 1−3/4 x 25) (E2)
5 502−0199 1 Elbow, Male − Inverted 14 526−0008 2 Washer, Flat (#10)
(45) 15 870−0131 1 Nut, Hex (#10−32)
6 416−1000 1 Cable, Battery (24”) 16 193−0448 1 Sender, Oil Pressure (E1)
7 416−0619 1 Cable, Battery (18”) 17 416−1019 1 Boot, Battery − Red
8 309−0641−20 1 Switch, Pressure − Oil (S5) 18 416−1084 1 Boot, Starter − Red
2 4
19 11
20 20 19
21 21 20
22 22 21
23 26 22
24 27 23
25 24
13
14
15 5
16
8
12 3
2
10
1
4
1
4 6
11 17
7 18
2 4
19 11
20 20 19
21 21 20
22 22 21
23 26 22
24 27 23
25 24
13
14
15 5
16
8
12 3
2
10
1
4
1
4 6
11 17
7 18
18
3
16
17
15
19
13
6
12
9
10 7
11 12
14
2
8
1
2
8
2 2 4 5
8 8 20
21
1 856−0013 1 Washer, Lock − EIT (1/2) 11 800−2058 1 Screw, Cap − Hex Head
2 800−2111 4 Screw, Cap − Hex Head (M8 x 25)
(M12 x 25) 12 193−0432 2 Sender, Temperature
3 502−0199 1 Elbow, Male − Inverted (45) (E2, E4)
4 416−1000 1 Cable, Battery (24”) 13 193−0444 1 Sender, Oil Pressure (E1)
5 416−0619 1 Cable, Battery (18”) 14 102−1356 1 Gasket, Oil Drain
6 505−0019 1 Bushing, Reducer 15 098−6195−01 1 Label, Caution
(1/2” x 3/8”) 16 526−0027 1 Washer, Flat (13/16”)
7 102−1448−02 1 Adapter, Oil Drain 17 332−1993 2 Terminal, Receptacle (.25)
8 526−2140 4 Washer, Flat (M12) 18 150−2331 1 Actuator, Linear
9 309−0269 1 Sender, Low Engine 19 332−3196 1 Clamp, J
Temperature (S4) 20 416−1019 1 Boot, Battery − Red
10 850−2008 1 Washer, Lock (M8) 21 416−1084 1 Boot, Starter − Red
17 2
20 17
21 20
22 21
23 22
24 23
26 25
15
16
17
13
6
12
9
10 7
11 12
14
2
8
1
2
8
2 2 4 5
8 8 18
19
1 856−0013 1 Washer, Lock − EIT (1/2) 13 193−0444 1 Sender, Oil Pressure (E1)
2 800−2111 5 Screw, Cap − Hex Head 14 102−1356 1 Gasket, Oil Drain
(M12 x 25) 15 526−0027 1 Washer, Flat (13/16”)
3 502−0199 1 Elbow, Male − Inverted (45) 16 332−1993 2 Terminal, Receptacle (.25)
4 416−1000 1 Cable, Battery (24”) 17 332−3196 3 Clamp, J
5 416−0619 1 Cable, Battery (18”) 18 416−1019 1 Boot, Battery − Red
6 505−0019 1 Bushing, Reducer 19 416−1084 1 Boot, Starter − Red
(1/2” x 3/8”) 20 130−3861 2 Bracket, Tube − Mounting
7 102−1448−02 1 Adapter, Oil Drain 21 821−2033 2 Screw, Hex − Flange Head
8 526−2140 5 Washer, Flat (M12) (M6 x 1 x 16)
9 309−0269 1 Sender, Low Engine 22 870−2054 2 Nut, Hex − Flange (M6 x 1)
Temperature (S4) 23 800−2085 1 Screw, Cap − Hex Head
10 850−2008 1 Washer, Lock (M8) (M10 x 1.5 x 20)
11 800−2058 1 Screw, Cap − Hex Head 24 526−2120 1 Washer, Flat (M10)
(M8 x 25) 25 850−2010 1 Washer, Lock − Split (M10)
12 193−0432 2 Sender, Temperature 26 850−2012 1 Washer, Lock − Split (M12)
(E2, E4)
17 2
20 17 17
21 21 20
22 22 21
23 27 22
24 28 23
26 25
15
16
17
13
6
12
9
10 7
11 12
14
2
8
1
2
8
2 2 4 5
8 8 18
19
1
2
H563
8
7
1 6
5
2
4
3 H268
1 102−1147 1 Gasket, Drain − Oil Pan 7 800−2111 1 Screw, Cap − Hex Head
2 102−1237 1 Adapter, Oil Drain (M12 x 1.75 x 20)
3 505−0050 1 Elbow, Street (1/2NPT x 90 8 503−0197 1 Clip, Hose − Corbin
degrees) 9 503−0098 − Hose, Drain − Bulk (Order By
4 504−0011 1 Valve, Shutoff (1/2) The Foot − 2 Feet
5 502−0827 1 Hose, Barb (1/2 x 3/4) Required)
6 518−0548−02 1 Clamp, Hose
3
1
2
12
5
7
11
6
4
9
10
6
13 7
CP01
12 11
1
2
7
10
9
8
5
9
4
5
CP01
8
19 6 11 7 12 9 14 13 10 8 5 3 2 6 3 2
15 4 1
16
17
18
C167,168,169
9 10 8
3 14 7 6 11
12 5 4
13
1 2
C115
8
9
11
Section A−A
2
8
6
4
12 1 8 3 10 7 5
C149
12
5
7
13 11 1 6 13 8
9
14 1
2 8 4
C115
10
13 2
12
16
11
13
14
20 9
3 10
8 18
5
1 4
21 15
19
6
7
17
19
17 16
19
18 15
14
13
12
11
4 2
7
9 6
8
5
20
10
C173
H573
7
1
H574
3
4
A299
A298,379
A299
3
4
7
3
4
7
2 A298,379,F182
6
7
3 14
13
7
2
8
3
12
11 10
A374
6
4
5
5
7 1
5
8
A373
1
11 4
1
5
6
7
10
F172,F173
1
7
11
11
5
6
10
F172,173
2
1
A379
4
1
8
6
3 5
H560
6
4
1 193−0468 1 Sender, Low Coolant Level 5 323−1709 4 *Socket, Contact (Used in S3)
2 338−3442 1 Harness, Low Coolant Level 6 323−1708 4 *Seal, Cable
Sender
3 338−3594 1 Harness, Pigtail (Includes
Parts Marked *) * − Parts Included in 338−3594 Pigtail Harness
4 323−1765 1 *Housing, Connector (4 Pin)
H389,527
1 193−0468 1 Sender, Low Coolant Level 2 338−3756 1 Harness, Low Coolant Level
Sender
3
6
5 7
10
8
4
7
8 9
8
11 3
3
2 A292,H036,074,504,505
H487,479
7 7
6
2
9 8
10
11
7
E043
3 16 25
1
27 26
28
30
13
12
24
18
19 17
23 20 3
15
15
21
13 22 7
14
2
10 8
11
4
6
29
11
4 16
20
1
13 4
12 11
17
13
15 7
13
11 8
14 9
5
10
19 11
18
1 3
5
4
F172,F173
9
5
3
4 1
2
15
4 6
16
6
3
7, 8
1
6
12
5
24
2
1
6
4
6 25
5 15
26
11 1
7
9
6 6
10
23
7 4
8
19 16
1 405−5908 2 Panel, Side − Radiator 12 821−6007−02 28 Screw, Hex Head (M8 x 20)
Housing 13 155−3238 4 Cover, Exhaust
2 405−5910 1 Panel, Front − Radiator 14 818−0237−01 6 Rivet, Pop
Housing 15 098−4500 2 Label, Prototype
3 405−6018 1 Roof 16 895−0382 10 Bumper, Door
4 405−5745 2 Post, Center − Housing 17 098−4730 1 Label, Warning
5 406−0831 10 Hinge, Housing 18 098−5429 1 Label, Coolant Fill
6 405−5832 4 Door, Housing 19 405−5902 1 Door, Housing − Sets Without
7 405−5916 2 Post, Corner − Housing Window
8 405−5903 1 Door, Housing − Sets With 20 870−0504 2 Nut, Captive Floating
Window (M6 x 1.0)
9 895−0363 − Weather Strip − Window − 21 821−6006−01 2 Screw, Hex Head (M6 x 16)
Bulk (Order By The Foot − 22 128−0154−02 1 Insulation, Foam
5 Feet Required) 23 406−0972−01 5 Latch, Door
10 319−2653 1 Control, Window (If 24 526−0451 2 Washer, Flat (M8)
Equipped) 25 098−7902−03 2 Label, Logo
11 818−0231−02 60 Rivet, Pop 26 098−4732 2 Label, Warning
24
25
16 26
22 14
14
13
21
3
13
27
15
2
17
1 19
6 12
18
4
7
6
11
1
5
6
9
4
20
6
10
8 7
23
27
28 29 41
30
31
40
26
31
21
22
24
39
20
31
21
32
18
15
23 17
14
16
25
11
10
7 19
13 9
43
8
5 6
44
1
35
1
12
38
42
37 33
3 4 F172
34 2 33
36
20, 59, 60
20 7
49
8
28
44
50
31 61
6 44
40
37 43
32 18
21
34 47
25 45
27 5 29
38
37
62
33, 58
14
48
23 26 55
26 39 10
17
4 30 9
6
57
19 24
36
56 41
22 35
12
15
3 13 15
19
12
54
46
16 42
11 4
2
51
52
52
53
1
53
20, 59, 60
20 7
49
8
28
44
50
62
31
6 44
40
37 43
32 18
21
34 47
25 45 63
27 5 29
38
37
33, 58
14
48
23 26 55
26 39 10
17
4 30 9
6
19 24 61
36
56 41 57
22 35
12
15
3 13 15
19
12
54
46
16 42
11 4
2
51
52
52
53
1
53
F172
32
33 34 48
35
36
47
31 29
27
36
25
30 25 21
22
24
27
29
20 46
36
21
37
18
15
23 17
14
16 28
11
9
10
7 19
8
26 50
13
6 12
5 51
26
1 41
1
40
45
49
42
44 38
7
26
42 F173
3 4
39 2 38
43
22, 70, 71
22 9
54
60
10
38
67
52 37 73
61
33 47 44
4
30
8 52
48
43 51
34 57
23
72
40 56
27 53 1
29 7 31
45
43 20
35, 69 39
16
59
25 28
28 46 12
47
19
6 32 11
8 58
21 68
26
42
67 49 66
24 41
14
17 36
5 15 17
21
14 65
55
18 50
13 6
3
62
63
63
64
2
64
F173
22, 70, 71
22 9
54
60
10
38
67
52 37 73
61
33 47 44
4
30
8 52
48
43 51
34 57
23
72
40 56
27 53 1
29 7 31
45
43 20
35, 69 39
16
59
25 28
28 46 12
47
19
6 32 11
8 58
21 26 74
42
67 49 68 66
24 41
14
17 36
5 15 17
21
14 65
55
18 50
13 6
3
62
63
63
64
2
64
F173
10 6
7
7 12
8
5
7 8
8 3
7 10
2
4
8 5
9
11
1
11
F177
10
11
6 3 12
8 7 7
8
1 14 13 2
10
2 11
9
7
8
F176,179
9
6
7 7
11
8
5 8
7
7 3
14
2
4
8
12
5
13 10
1
12
15
16
F177
10 12
5
5 11
4
8 4
5 5 8
14 3
4 2
6 9 7
13 1
17
6
15
16
18
F176,179
F170
1
2
F172,173
1 159−1467 1 Cover, Fuel Tank 2 821−6003−02 6 Screw, Hex Head (M8 X 20)
3 5 4
2 1
F065
F176
3 5 4
F065
2 1
4
5
5 4
1 416−1069 1 Cover, Battery Tray 4 821−6003−02 8 Screw, Hex Head (M8 x 1.25
2 416−1099−02 1 Cover, Battery Tray − LH x 20)
3 416−1098−02 1 Cover, Battery Tray − RH 5 526−0399−42 8 Washer, Flat
CP01
3 4
1 6
CP01
4 5
A367
5
1
A366,A367
2
3
8 3
9
8 11
12
3
16
14
15
1 6
13
17
18 4
19
10
2
20
10
1 319−3072 2 * Panel, End − Circuit Breaker 8 526−0008 4 *# Washer, Flat (#10) (Used
Box with F Frame Only)
2 319−2978 2 * Panel, Side − Circuit Breaker 9 *# Nut, Lock
Box 870−0221 4 TQD E Frame (#8−32)
3 098−2304 1 *# Label, Warning 870−0131 4 F Frame (#10−32)
4 * Cover, Box − Circuit Breaker 870−0232 4 J T JD Frame (1/4−20)
319−2979−02 1 Entrance Box Only (No 10 Screw, SEMS − Hex Head
Breaker) (M6 x 1 x 16)
319−2979−01 1 Used with Circuit Breaker 821−6002−03 8 No Breaker
5 *# Cutout, Box − Circuit Breaker 821−6002−03 24 Entrance Box Only (No
319−3012 1 110−225 Amp, 3 Pole, TQD Breaker)
Frame (Hole Size 76mm 821−6002−03 28 Used with Circuit Breaker
x 32mm) 11 508−0239 − * Edging − Bulk (Order By
319−3013 1 0−100 Amp, 3 Pole, E The Foot − 2 Feet
Frame (Hole Size 98mm Required)
x 36mm) 12 319−2980 1 *# Bracket, Mounting − Circuit
319−3013 1 125−225 Amp, 3 Pole, E Breaker (UL)
Frame (Hole Size 98mm 13 332−2744−07 1 Standoff, Insulator (3 Pole
x 36mm) Only)
319−3014 1 125−225 Amp, 3 Pole, F 14 821−6003−02 1 * Screw, SEMS − Hex Head
Frame (Hole Size 98mm (M8 x 1.25 x 20)
x 76mm) 15 332−1473 1 * Lug, Solderless
319−3014 1 250−425 Amp, 2 Pole, J T 16 856−0008 1 * Washer, Lock − EIT (5/16)
TD Frame (Hole Size 17 800−0048 2 Screw, Cap − Hex Head
98mm x 76mm) (3/8−16 x .75) (3 Pole Only)
319−3014 1 250−425 Amp, 3 Pole, J T 18 850−0050 2 Washer, Lock (3/8) (3 Pole
TD Frame (Hole Size Only)
98mm x 76mm) 19 526−0029 1 Washer, Flat (3/8) (3 Pole
319−3014 1 450−600 Amp, 2 Pole, J Only)
Frame (Hole Size 20 098−6537 1 Label, Ground
98mm x 76mm)
6 818−0231−02 4 *# Rivet, Pop
7 *# Screw, Machine − Round * Not used on sets WO/Breaker or Entrance Box
Head
812−0093 4 TQD E Frame
(#8−32 x 3) # Not used on sets W/Entrance Box Only − No Breaker
813−0190 4 F Frame (#10−32 x 4)
812−0157 4 J T JD Frame (1/4−20 x
1.75)
1 2
9
11
10
7
4 12
5 13
8
14
6
15 3
16
17
19
18
5
4
12
13
11
15
16
7 1
10
9 6
8
14
2
20
14
1 2
16
7 9
8
12
11
10 15
14
5 18
17
13
A292,293
15
7 9 3
8
12 6
11 1
2
10
5
16
13
14
17 5
A292,293
5 7
15 6
18 14
3
16 10 13
9
49 12 8 4
11
21 19
50
2 52
23 53
57 17 22
54
56
55
39
32
38 30
24 34 54
48
28 31
51 37
29
58 26
42 39
20 38
25
40
62 41
1
27
59 33 30
29
61
28
60 36
35
47 45
44
45 46 44
43
5 7
15 6
18 14
3
16 10 13
9
49 12 8 4
11
21 19
50
2 52
23 53
57 17 22
54
56
55
39
32
38 30
24 34 54
48
28 31
51 37
29
58 26
42 39
20 38
25
40
62 41
1
27
59 33 30
29
61
28
60 36
35
47 45
44
45 46 44
43
11
10
16 8
12
3 13 18 9
7 5
17 9
14
6
15
2
A363,363
A362,363
12
13
10
8
7
11
5
6
5
1
4
9
2 3
B240
2
6
1
5 B184
B184
5
11
9
3 2
10
CP01
26 25
32 29 31
27
28 30
7
12
16 9
17 10
1 18
6
8
24
8
19 5
22 11
34
23
35
21
34
33
4
8
8
2 8
8
11
13
36
7
3
14 20
H562
15
27
33 36
39 34 9 38
3 35
51
39
4 10 41
39 11 50
30
40 31 19 17
46 25 12
42 32 24 26 18 16
53 37
43 5 (6−8)
(28,47,
54) 52 15
37
44
37
22
45
13
14
1 2 48 20 21 23
49 24
55
2 29
1
2 13
3
12
14 6
10 8
11
9 7
H568
3
8
16 9
7
10
11
17
12
20 13
28
14
27 21
22
18
5
6
19
29
4
25
30
31 15
32 26
33
24
18
23
H530
3
8
16 9
7
10
11
17 33
12
20 13
28
14
27 21
22
32
18
34
5
6
19
29
4
25
30
15
26
31
24
18
23
H530
3
8
16 9
7
10
11
17 32
12
20 13
28
14
27 21
22
31
18
33
5
6
19
29
4
25
30
15
26
24
18
23
H530
26 2 7 8
3
28
4
27
11 13
12
9
15
10 16
14 21
23
25
17
20 18
22
19
24
H562,559,560
4
5
8
9
B184,240
6
7
8
3
1
5
4
5
B240,184
KL39
12
8
4
2
11
5 10
H560
4
1
KA08
KL39
H573,H574
1
3
H562
3
4
5
3
4
KL39
6
3
5
11
15
8 4
2
14
7
13
10
12
9
11
1 2
6 5
H560,543
8 4
9
7
10
5 7
1
2
K185
A068
4
3
2
K486
H559,560,562,530,532,555
2
7
3
5
H559,560,562
4
1 Contact, Auxiliary
320−1747−13 1 1 Contact
320−1747−14 1 2 Contact
1
2
3
4
5 7
Continued...
1
2
3
4
5 7
3
4 2
3
4 2
4 14 15 2
21
5 3 12
10
11
6
7
8 22 13 17 16
19 18
CP01
20 19
1 300−5498−02 A/R Cover, Control Door − Meters 2 870−0131 A/R Nut, Hex − W/ET (#10−32)
These parts must be purchased through the Accessories Business Unit, see your Cummins/Onan Distributer. For
other accessories such as batteries, fuel tanks and annunciators contact the Accessories Business Unit.
140−3053, 30 155−3116, 41
140−3054, 31 155−3117, 42 , 44
140−3055, 30 155−3118, 44
140−3056, 31 155−3120−01, 44
140−3063, 30 , 31 155−3120−02, 40
140−3067, 31 155−3125, 42 , 44
149−2441, 37 155−3166, 46
150−0723, 110 155−3167, 46
150−0956, 110 155−3168, 46
150−2201, 91 155−3176, 45
150−2331, 22 155−3193, 47
155−3196, 40
150−2331−00, 90
155−3219, 46
150−2578, 90
155−3238, 63 , 65 , 69 , 71 , 75 , 77
150−2735−01, 91
155−3248, 156
151−0402, 143
155−3260, 47
151−0715−01, 90
155−3374, 156
151−0731−01, 91
159−1371−03, 32
151−0754−02, 91
159−1371−05, 32
154−2708, 40 , 43 , 44 , 45 , 46
159−1378, 32
155−2062−01, 43
159−1439, 37
155−2062−10, 45 , 46
159−1467, 83
155−2063−03, 156
159−1468, 34
155−2064−03, 156
159−1472, 33
155−2065−03, 156
159−1481, 35
155−2175, 43 , 44 , 45 , 46 , 47
191−1981, 89
155−2340−07, 156
191−2209−01, 89
155−2341−07, 156 191−2211, 88
155−2342−07, 156 193−0250, 117
155−2565, 41 , 42 , 43 , 44 , 45 , 46 193−0351, 117
155−3064, 43 193−0375, 16 , 19 , 21
155−3066, 43 193−0388, 144
155−3074, 45 193−0432, 22 , 25 , 27
155−3082, 43 193−0435, 144
155−3086, 43 193−0444, 22 , 25 , 27
155−3102−01, 43 193−0448, 16 , 19 , 21
155−3102−02, 45 , 46 , 47 193−0451, 28
155−3114, 44 193−0463, 28
155−3115, 44 , 47 193−0466, 117
405−5438, 67 , 73 405−5955, 69 , 71 , 75 , 77
405−5625, 67 , 73 405−5956, 69 , 71 , 75 , 77
405−5627, 67 , 73 405−5957, 69 , 71 , 75 , 77
405−5628, 67 , 73 405−5958, 69 , 71 , 75 , 77
405−5630, 67 , 73 405−5960, 69 , 71 , 75 , 77
405−5637, 73 405−5961, 69 , 71 , 75 , 77
405−5638, 67 , 73 405−5966, 69 , 71 , 75 , 77
405−5679, 62 , 67 , 73 405−5987, 69 , 71 , 75 , 77
405−5682, 62 , 67 , 73 405−5988, 75 , 77
405−5684, 62 , 67 , 73 405−5990, 75 , 77
405−5685, 62 , 67 , 73 405−5991−01, 75 , 77
405−5687, 67 , 73 405−5991−02, 75 , 77
405−5995, 69 , 71 , 75 , 77
405−5689, 67 , 73
405−5996, 69 , 71 , 75 , 77
405−5704, 67 , 73
405−5997, 69 , 71 , 75 , 77
405−5705, 67 , 73
405−5998, 69 , 71 , 75 , 77
405−5706, 67 , 73
405−6000−02, 69 , 71 , 75 , 77
405−5707, 67 , 73
405−6000−03, 69 , 71 , 75 , 77
405−5709, 67 , 73
405−6000−04, 75 , 77
405−5710, 67 , 73
405−6000−06, 69 , 71 , 75 , 77
405−5720, 67 , 73
405−6000−07, 75
405−5721, 67 , 73
405−6001−01, 69 , 71 , 75 , 77
405−5722, 67 , 73
405−6003, 69 , 71 , 75 , 77
405−5731, 73
405−6005, 69 , 71 , 75 , 77
405−5732, 73
405−6010, 75 , 77
405−5733, 67 , 73
405−6013, 75 , 77
405−5734, 69 , 71 , 73 , 75 , 77
405−6014, 75 , 77
405−5735, 62
405−6015, 69 , 71 , 75 , 77
405−5745, 63 , 65 , 69 , 71 , 75 , 77 405−6018, 63 , 65 , 69 , 71 , 75 , 77
405−5760, 73 405−6029, 69 , 71 , 75 , 77
405−5832, 63 , 65 405−6030, 69 , 71 , 75 , 77
405−5841, 69 , 71 , 75 , 77 405−6034, 69 , 71 , 75 , 77
405−5902, 63 , 65 , 69 , 71 , 75 , 77 405−6035, 69 , 71 , 75 , 77
405−5903, 63 , 65 , 69 , 71 , 75 , 77 405−6044, 75 , 77
405−5908, 63 , 65 , 69 , 71 , 75 , 77 405−6068, 69 , 71 , 75 , 77
405−5910, 63 , 65 , 69 , 71 , 75 , 77 405−6109, 69 , 75
405−5916, 63 , 65 , 69 , 71 , 75 , 77 405−6132, 75 , 77
405−5952, 69 , 71 , 75 , 77 405−6926, 71 , 77
405−5953, 69 , 71 , 75 , 77 405−6927, 77
405−5954, 69 , 71 , 75 , 77 406−0332, 117
416−0993−02, 84 , 86 503−1870−05, 30 , 31 , 45
416−1000, 12 , 13 , 16 , 19 , 22 , 25 503−1870−06, 30
503−1929, 55
416−1003−02, 85
503−2003, 55
416−1019, 13 , 15 , 16 , 19 , 21 , 22 , 25 , 27
503−2003−01, 55
416−1033, 84 , 85 , 86
503−2029, 30
416−1069, 87
503−2032, 31
416−1084, 12 , 13 , 15 , 16 , 19 , 21 , 22 , 25 , 27
503−2149, 57
416−1089, 21 , 27
503−2150, 57
416−1093, 15 , 21 , 27
503−2157−01, 51
416−1098−02, 87
504−0003, 55 , 57
416−1099−02, 87
504−0011, 29 , 55
501−0502, 32 , 33 , 154
504−0176, 59
501−0627−03, 32 , 33 , 154
505−0007, 32 , 33
502−0029, 37 505−0019, 22 , 25 , 27 , 51
502−0047, 37 505−0026, 38 , 39
502−0050, 37 505−0027, 32 , 33
502−0053, 28 505−0050, 29
502−0085, 55 505−0066, 38
502−0199, 12 , 13 , 15 , 16 , 19 , 21 , 22 , 25 , 27 505−0069, 39
502−0426−01, 59 505−0110, 32 , 33
502−0433, 37 505−0117, 55
502−0827, 29 505−0172, 32
508−0239, 95 , 97 , 99 526−0399−59, 35
856−0013, 12 , 13 , 15 , 16 , 19 , 21 , 22 , 25 , 27 870−2054, 13 , 15 , 19 , 21 , 25 , 27 , 34 , 35
, 78 , 79 , 80 , 81 870−2064−01, 100 , 103
860−0008, 36 , 142 870−2193−04, 67 , 73
860−0012, 99 870−2204, 119
860−2005, 97 , 100 , 101 , 103 871−0015, 117
860−2006, 37 , 89 , 97 , 103
895−0363, 63 , 65 , 67 , 69 , 71 , 73 , 75 , 77
860−2008, 89
895−0382, 63 , 65
860−2009, 105
895−0384, 69 , 71 , 75 , 77
862−0001, 110 , 133
895−0385, 69 , 71 , 75 , 77
862−0026−58, 32
895−0386, 69 , 71 , 75 , 77
862−0044, 80 , 81
898−0025, 131
864−0011, 37
898−0860, 108
865−0030, 84 , 85 , 86
898−1195−01, 108
866−0014, 90
898−1254−19, 101
870−0048, 140
A029S556, 32
870−0131, 16 , 19 , 21 , 95 , 117 , 119 , 140 , 155
A029S559, 32