0 évaluation0% ont trouvé ce document utile (0 vote)
11 vues1 page
The document discusses setting up equipment for gas absorption and batch distillation experiments. It notes that a table needs to be set up by the end of next week for post-distillation work, and CO2 probes need to be tested by Wednesday. It also addresses checking the gas chromatography needle inventory and setting up all glassware and electronics for batch distillation by Tuesday. Finally, it mentions having a team discussion about water issues and providing keys to certain individuals.
The document discusses setting up equipment for gas absorption and batch distillation experiments. It notes that a table needs to be set up by the end of next week for post-distillation work, and CO2 probes need to be tested by Wednesday. It also addresses checking the gas chromatography needle inventory and setting up all glassware and electronics for batch distillation by Tuesday. Finally, it mentions having a team discussion about water issues and providing keys to certain individuals.
The document discusses setting up equipment for gas absorption and batch distillation experiments. It notes that a table needs to be set up by the end of next week for post-distillation work, and CO2 probes need to be tested by Wednesday. It also addresses checking the gas chromatography needle inventory and setting up all glassware and electronics for batch distillation by Tuesday. Finally, it mentions having a team discussion about water issues and providing keys to certain individuals.
Table (between GA and Dist) setup (Post-Distillation Column installation???)
o By end of next week before start of term. Laptop setup and install CO2 probes o Test by Wednesday… Will not be installed until the table is set up. Check GC needle inventory (Is there a GA storage box?) o We used BD 1mL syringe last time. Out of stock! o Could find 1mL Norm-Ject syringe (75 syringes available) o No needles available though. We used BD PrecisionGlide Needle (25G x 1) (0.5mm x 25mm) last time
CO2 Probe (Review SOP to keep the probes dry)
Add line about contacting Lab engineers
Batch Distillation:
Setup all glassware and sensors
Setup all electronics (mantle control, laptop, MiniGC, and cables)
o Started setting up batch distillation. Will be done by Tuesday. Where shall we move all the boxes?
Miscellaneous:
Team discussion on water pulls on east wall (esp. Andy, Phil, John, PJ)
Angela M. Cirucci, Urszula M. Pruchniewska - UX Research Methods For Media and Communication Studies - An Introduction To Contemporary Qualitative Methods