Académique Documents
Professionnel Documents
Culture Documents
1 OBJETIVO
Este procedimento busca auxiliar o acesso via Craft Terminal, ao radio 9500MPR-e Full
Outdoor, quando instalado com a IDU - Power Injector Box ou MPT Power Unit.
2 REFERENCIAS DA IDU
Connectors
. Two DC connectors in the front (for box version), or power from the backpanel (for plug-in version).
User Manual
Product information and planning
9500 MPR for ETSI RELEASE 4.2.0
168/1232 3DB19901ACAA Issue 01
. Two RJ45 for the data in (DATA)
. Two RJ45 for the data + DC out (DC+DATA)
LEDs
. Two LEDs indicate the presence of DC voltage on each Ethernet output.
Note: The power source "battery" is isolated from AC power main feeds.
A 2-wire power cable (2x1 mm2 - AWG17) is supplied (1AC007800068).
Note: Power cable gauge smaller than 2x1 mm2 (AWG 17) is not allowed for proper operation of the
Power Injector box.
The blue wire must be connected to -48 Vdc (live); the black wire to + (Return).
The cable must be screwed to the Power Injector box and to the battery.
Note: The Power supply must be connected to a fuse or a breaker on a customer power distribution
box. The recommended value is 3 Amps for one ODU and 6 Amps for two ODU
OBSERVAÇÃO:
PARA ACESSAR A ODU UTILIZANDO A IDU MPT POWER UNIT, SERÁ NECESSÁRIO TER EM
MÃOS O CONVERSOR OPTICO PARA RJ45, OU UTILIZAR UMA PORTA RJ45 DO ROTEADOR.
O primeiro passo é verificar se o Laptop cria VLAN na porta ETHERNET (RJ45), seguindo o passo a
passo apresentando nas telas abaixo:
Caso não permita criar a VLAN, deve-se fazer a atualização do drive, de acordo com o fabricante do
adaptador de rede.
Clicar em propriedades, configurar a VLAN 4080, conforme apresentado nas telas abaixo:
4 ACESSANDO A ODU
Para acessar o ODU Stand Alone é necessário utilizar o MCT Craft, que está localizado na mesma
pasta onde se encontra o NEtO. (WebEML)
Pasta 9500MCT_V07.03.01.
MCT
Aparecerá, esta mensagem abaixo, clicar em Accept > NEXT > (configuração OnLine)
Selecione o item Protection marque 1+0 (nesta versão só há esta possibilidade). Clique em Apply.
Faça a Rota estática p/ que os demais elementos possam enxergar via TMN a ODU.
Para o exemplo acima os Rádios da Rede eram todos com endereço IP 10.0.x.x .
Tx Power local
Rx remoto
Tx Power local
Rx local
RX
Tx Power local local TX Power remoto
Rx local
ATENÇÃO:
AO TROCAR OS IPs, para colocar conforme a DCN da regional, TROCAR UM ITEM DE CADA VEZ,
CONFORME A SEGUIR:
1) IP ADDRESS NE;
2) IP ADDRESS TMN IN-BAND;
3) MASK TMN IN-BAND;
4) VLAN ID TMN IN-BAND.
E ANOTAR A NOVA CONFIGURAÇÃO, POIS SE PERDER TERÁ QUE ENVIAR A ODU PARA FABRICA
RESETAR A CONFIGURAÇÃO DE IP E RECUPERAR O ACESSO A ODU.